You are on page 1of 4

L

General Information
General Information

HANDLING CHARACTERISTICS WARNINGS AND SYMBOLS


The following warnings, cautions and symbols
WARNING
used within the handbook call your attention to
Your vehicle has a higher ground clearance
specific types of information.
and hence, a higher center of gravity than
ordinary passenger cars, to enable the Warnings
vehicle to perform in a wide variety of off-road
applications. An advantage of the higher WARNING
ground clearance is a better view of the road Safety warnings are included in this
allowing you to anticipate problems. handbook. These indicate either a procedure
which must be followed precisely, or
The vehicle is not designed for cornering at
information that should be considered with
the same speed as conventional passenger
great care in order to avoid the possibility of
cars any more than a low slung sports car is
personal injury.
designed to perform satisfactorily under
off-road conditions. If at all possible, avoid
sharp turns or abrupt manoeuvres. As with Cautions
other vehicles of this type, failure to operate Caution: Cautions are included in this
the vehicle correctly may result in loss of handbook. These indicate either a procedure
control or vehicle rollover. For important which must be followed precisely, or
safety information, be sure to read the driving information that should be considered with
guidelines given later in this handbook. See great care in order to avoid the possibility of
GENERAL DRIVING ADVICE, 144. damage to your vehicle.
Symbols
This recycling symbol identifies those
items that must be disposed of safely in
order to prevent unnecessary damage to
the environment.
This symbol identifies those features
that can be adjusted or disabled/enabled
by a Land Rover Retailer.

22
R

General Information
WARNING LABELS ATTACHED Labels are attached to your vehicle at several
TO THE VEHICLE positions. These are applied to draw your
attention to important subjects, e.g. tire
Warning labels attached to your
pressures, tow bar use, airbags, roll-over risk,
vehicle bearing this symbol mean: DO
engine compartment hazards, etc.
NOT touch or adjust components until
you have read the relevant It is important that you are familiar with these
instructions in the handbook. subjects to ensure that your vehicle and its
features are used safely. Using the index at the
Labels showing this symbol indicate
back of this handbook, refer to the relevant
that the ignition system utilises very
topic for more information.
high voltages. DO NOT touch any
ignition components while the starter
ANTI-THEFT PRECAUTIONS
switch is turned on.
Take vehicle security very seriously and
ALWAYS adopt this simple four point drill
MFD BY LANDROVER IN THE UK
whenever you leave your vehicle - even for just
DATE : MM/YY GVWR: XXXXKG (XXXXLB) a few minutes:
GAWR FRONT: XXXXKG (XXXXLB)
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
1. Fully close all the windows (and the
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
sunroof).
TXXX/XXRXX TIRES, X.XJxXX RIM, AT XXXKPA (XXPSI) COLD
GAWR REAR: XXXXKG (XXXXLB)
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
2. Remove your valuable belongings (or hide
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
them out of sight).
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
XXX/XXRXX TIRES, X.XJxXX RIMS, AT XXXKPA (XXPSI) COLD
TXXX/XXRXX TIRES, X.XJxXX RIM, AT XXXKPA (XXPSI) COLD 3. Remove the starter key.
THIS VEHICLE CONFORMS TO ALL APPLICABLE
U.S.FEDERAL MOTOR VEHICLE SAFETY
STANDARDS IN EFFECT ON THE DATE OF 4. Lock the vehicle using the remote control.
MANUFACTURE SHOWN ABOVE

TESTMARK1234567890 Thieves are attracted by vulnerable vehicles.


Even if you have followed the four point drill,
TYPE : MULTI - PURPOSE PASSENGER VEHICLE there is still much you can do to make your
vehicle a less inviting target.
BE SAFE - NOT SORRY!
• Park where your vehicle can be easily seen
by householders and passers-by.
• At night, park in well lit areas and avoid
deserted or dimly-lit side streets.
TIRE AND LOADING INFORMATION
SEATING CAPACITY TOTAL 5 FRONT 2 REAR 3
• NEVER leave the keys in the vehicle.

The combined weight of occupants and cargo should never exceed XXXkg or XXXXlbs
TIRE SIZE COLD TIRE INFLATION PRESSURE SEE OWNER’S Do not keep important documents (or
FRONT XXX/XXRXX XXPSI XXXkpa MANUAL FOR spare keys) in the vehicle - these are a real
RTC500490

XXX/XXRXX
ADDITIONAL
XXPSI XXXkpa
REAR
SPARE TXXX/XXRXX XXPSI XXXkpa
INFORMATION bonus for the thief.

H6729N

Example

23
L

General Information
DATA RECORDING CALIFORNIA PROPOSITION 65
Service data recording
WARNING
Service data recorders in your vehicle are WARNING
capable of collecting and storing diagnostic Engine exhaust, some of its constituents and
information about your vehicle. This potentially certain vehicle components contain or emit
includes information about the performance or chemicals know to the State of California to
status of various systems and modules in the cause cancer and birth defects or other
vehicle such as engine, throttle, steering or reproductive harm. In addition, certain fluids
brakes. contained in vehicles and certain products of
In order to properly diagnose and service your components wear contain o r emit chemicals
vehicle, Land Rover or other service and repair known to the State of California to cause
facilities may access vehicle diagnostic cancer and birth defects or other reproductive
information through a direct connection to your harm.
vehicle.
Event data recording WARNING
Event data recorders are capable of collecting Battery posts, terminals and related
and storing data during a crash or near-crash accessories, contain lead and lead
event. The recorded information may assist in compounds. Wash hands after handling.
the investigation of such an event. The modules
may record information about both the vehicle
and the occupants, potentially including
information such as:
• How various systems in your vehicle were
operating.
• Whether or not the driver and passenger
seat belts were buckled.
• How far, if at all, the driver was depressing
the accelerator and/or the brake pedal.
• How fast the vehicle was travelling.
• Where the driver was positioning the
steering wheel.
To access this information special equipment
must be connected directly to the recording
modules. Land Rover do not access event data
recorder information without obtaining consent,
unless pursuant to court order or where
required by law enforcement, other government
authorities or third parties acting with lawful
authority. Other parties may seek to access the
information independently of Land Rover.

24
R

Reporting Safety Defects


Reporting Safety Defects

REPORTING SAFETY DEFECTS


(U.S. ONLY)
If you believe that your vehicle has a defect
which could cause a crash or could cause injury
or death, you should immediately inform the
National Highway Traffic Safety Administration
(NHTSA), in addition to notifying Land Rover
North America Inc.
If NHTSA receives similar complaints, it may
open an investigation and if it finds that a safety
defect exists in a group of vehicles, it may order
a recall and remedy campaign.
However, NHTSA cannot become involved in
individual problems between you, your Retailer
or Land Rover North America Inc.
Auto safety hotline
To contact NHTSA, you may call the Vehicle
Safety Hotline toll-free at 1-888-327-4236
(TTY: 1-800-424-9153); go to
http://www.safecar.gov; or write to:
Administrator,
NHTSA,
400 Seventh Street SW.,
Washington, DC 20590.
You can also obtain other information about
motor vehicle safety from
http://www.safecar.gov.

25

You might also like