Professional Documents
Culture Documents
Circuito Electrico Inter PDF
Circuito Electrico Inter PDF
S08342
02/24/2010
S08342
Copyright © 02/24/2010 International Truck and Engine Corporation
TRUCK SERVICE MANUAL i
Table of Contents
SAFETY INFORMATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
1 3100 BUS CIRCUIT DIAGRAMS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
S08342
ii TRUCK SERVICE MANUAL
S08342
TRUCK SERVICE MANUAL 1
SAFETY INFORMATION
IMPORTANT – Read the following before starting the service procedure.
The information contained in this International Service Manual Section was current at the time of printing
and is subject to change without notice or liability.
You must follow your company safety procedures when you service or repair equipment. Be sure to understand
all of the procedures and instructions before you begin work on the unit.
International uses the following types of notations to give warning of possible safety problems and to give
information that will prevent damage to the equipment being serviced or repaired.
WARNING – A warning indicates procedures that must be followed exactly. Personal injury
or possible death can occur if the procedure is not followed.
CAUTION – A caution indicates procedures that must be followed exactly. If the procedure is not
followed, damage to equipment or components can occur.
NOTE – A note indicates an operation, procedure or instruction that is important for correct service.
Some procedures require the use of special tools for safe and correct service. Failure to use these special
tools when required can cause injury to service personnel or damage to vehicle components.
This service manual section is intended for use by professional technicians, NOT a “do-it-yourselfer.” It is
written to inform these technicians of conditions that may occur on some vehicles, or to provide information
that could assist in the proper service of a vehicle. Properly trained technicians have the equipment, tools,
safety instructions, and know-how to do a job properly and safely. If a condition is described, DO NOT assume
that the service section applies to your vehicle. See your International Truck Dealer for information on whether
this service section applies to your vehicle.
S08342
2 TRUCK SERVICE MANUAL
S08342
1 3100 Bus Circuit Diagrams 3
Table of Contents
S08342
4 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 5
S08342
6 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 7
S08342
8 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 9
S08342
10 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 11
S08342
12 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 13
S08342
14 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 15
S08342
16 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 17
S08342
18 1 3100 Bus Circuit Diagrams
Figure 14 Battery
S08342
1 3100 Bus Circuit Diagrams 19
S08342
20 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 21
Figure 17 Horn
S08342
22 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 23
S08342
24 1 3100 Bus Circuit Diagrams
5. GAUGES (CHAPTER 5)
5.1. FUEL LEVEL, P. 1
S08342
1 3100 Bus Circuit Diagrams 25
Figure 21 Low Oil Press./High Water Temp., Stop Engine, Engine, Brake Warnings
S08342
26 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 27
S08342
28 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 29
S08342
30 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 31
S08342
32 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 33
Figure 29 Feed
S08342
34 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 35
S08342
36 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 37
S08342
38 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 39
9.7. GATEWAY, P. 7
Figure 35 Gateway
S08342
40 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 41
S08342
42 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 43
S08342
44 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 45
S08342
46 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 47
S08342
48 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 49
S08342
50 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 51
S08342
52 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 53
S08342
54 1 3100 Bus Circuit Diagrams
S08342
1 3100 Bus Circuit Diagrams 55
S08342
56 1 3100 Bus Circuit Diagrams
S08342
Printed in the United States of America