Professional Documents
Culture Documents
(WT2080)
Brochure
Introduction
WT2080 LED Power Driver Test Instrument is the comprehensive test instrument for
LED drive power which is according to GB/T 24825-2009 and IEC 62384:2006. It
can measure the following parameters: Input Characteristics Test (AC&DC), Output
Characteristics Test (AC&DC), Input Start Characteristics Test (DC)
The WT2080 usually works with LISUN LSP-500VAR pure sine AC Power Source,
LISUN M9822 DC Electronic Load to test LED Driver. The software can be run Win7,
Win8 and Win10.
Function
1. Input Characteristics Test (AC)
•To measure the input voltage, current, power, power factor, power grid frequency,
total harmonic and the harmonic component of 0 ~ 50 times, wave ratio, initial
phase angle, peak phase angle, the phase Angle.
• The fundamental frequency scope of the current and voltage : 45Hz~65Hz;
Narrowband range: 45 Hz ~ 5 kHz; Broadband range: 45 Hz ~ 1 MHz.
• Voltage range: 3 ~ 300 V (CF = 1.67); Current range: 5mA ~ 2.7A (CF = 3);
Power range: 0.015 ~ 800 W; Power factor range: 0.000 ~ + 1.000
-Page 1 -
Lisun Electronics Inc. Sales@Lisungroup.com www.Lisungroup.com
Specification
AC:
Items Basic error Measurement condition
Voltage
Current ±(0.1%read+0.1%range+1bit)
Power Input waveforms: sine
wave;
Power Factor ±(0.002+0.001/read+1bit)
Input frequency: 45Hz ~
Frequency ±0.1%read 65Hz;
Harmonic Wave
±(0.1%range+5%read)
(Valuable)
Lamp Voltage Input waveforms: sine
Lamp Current wave;
±(0.1%read+0.1%range+1bit) Input frequency: 45Hz~
Lamp Power 65Hz;
DC:
Voltage
Current ±(0.1%read+0.1%range+1bit) DC signal
Power
Lamp Voltage
Lamp Current ±(0.1%read+0.1%range+1bit) DC signal
Lamp Power
-Page 2 -
LED Driver Test Report Page 1 of 6 Pages
Voltage
Sensitivity: 306.54 V/Div
Peak: 306.54 V
Current
Sensitivity: 0.3565 A
Peak: 0.7130 A
Start Phase: 14.1°
Peak Phase: 63.3°
End Phase: 174.4°
Voltage Spectrum
THD(IEC): 3.56%
H3: 1.82%
H5: 2.92%
H7: 0.51%
H9: 0.28%
0 K 39
Current Spectrum
THD(IEC): 50.2%
H3: 18.69%
H5: 19.07%
H7: 14.84%
H9: 20.67%
0 K 39
Start characteristics
0.690(s)
55.69(V)
0.690(s)
0.7387(A)
Output
Lamp Voltage(rms):55.25V Lamp Current(rms):0.7164A
Power:39.58W Ripple Current:0.016A Energy Efficiency:0.899