Professional Documents
Culture Documents
𝑣𝑒𝑙𝑜𝑐𝑖𝑡𝑦 = 1𝑚/𝑠
𝑉𝑖𝑠𝑐𝑜𝑠𝑖𝑡𝑦 = 1𝑒 − 4 kg/(m-s)
𝑅𝑒𝑦𝑛𝑜𝑙𝑑𝑠 𝑛𝑜 = 10000
𝐿𝑒𝑛𝑔𝑡ℎ = 𝑙 = 1𝑚
Geometry:
The geometry was created by first drawing a rectangle. Then that rectangle was converted in to a
surface from concept tab. This is how it looked after the process.
Thickness:
The thickness was held zero. That is a 2 dimension problem was solved.
Meshing:
The meshing was done by setting 60 divisions in vertical direction and 50 divisions in horizontal
direction. This was done by using the feature of Sizing.
Biasing:
Divisons were biased using biasing tab only vertically. A bias factor of 70 was chosen.
Final Mesh:
Creating Named Selections:
Named selections were created so that our problem could be simplified while the boundary
conditions.
Setup:
In this step boundary conditions were given. Below is the image for inlet.
Solution:
SIMPLE scheme was selected with second order upwind. Then after initializing, the iterations
were set to 1000.
Solution Convergence:
The solution converged as shown in the figure below.
Results:
Below is the image of velocity contours drawn as POINTS and shown with lines.