Professional Documents
Culture Documents
BEAM ANALYSIS
a.Analyse the given beam using STAAD Pro. Cross section of the beam 200mm x 400mm.
Grade of Concrete M25. Grade of Steel Fe 415. Plot SFD, BMD and deflected profile.
b. Analyse the given beam using STAAD Pro. Cross section of the beam 250mm x 400mm.
Grade of Concrete M30. Grade of Steel Fe 415. Plot SFD, BMD and deflected profile
c. Analyse the given beam using STAAD Pro. Cross section of the beam 200mm x 400mm.
Grade of Concrete M25. Grade of Steel Fe 415. Plot SFD, BMD and deflected profile
d. Analyse the given beam using STAAD Pro. Cross section of the beam 200mm x 400mm.
Grade of Concrete M25. Grade of Steel Fe 415. Plot SFD, BMD and deflected profile.
DESIGN OF BEAM
b. Design a beam of span 6.5m to carry a uniformly distributed load of 15kN/m and two
concentrated loads of 75 kN each at 2m from either ends of a beam. The only rolled steel
section available is IS MB 350@514N/m (fy= 250MPa). Design a beam section if
compression flange is supported laterally.
ANALYSIS OF TRUSS
.
DESIGN OF TRUSS.
a. Design a howe type roof truss for a godown of size 10m x 40m. The truss is simply
supported on a 300mm thick brick wall.provided at a spacing of 5m. Galvanized
corrugated sheets are used as roof covering material, ISMC 100 channel sections are used
as purlins. Propose a suitable type of truss. Weight of galvanized corrugated iron sheets =
0.133kN/m2
Frame Geometry
230x450mm (I)
DESIGN OF
FRAMED
STRUCTURE
Draft the Bending Moment Diagram, Shear Force Diagram & Deflection Diagram.
Design the beams AB & BC. Also design one interior and one exterior column at ground
level. Frame Geometry 230 x 450 mm (I). Beams are of grade M 25 and columns are of
grade M30.Use Fe 415 steel. Assuming missing data suitably & should be clearly
indicated.
DESIGN OF MULTI STOREYED RCC FRAMED STRUCTURE
a) Analyse the building frame using STAAD.
The line sketch of a 3 storeyed (G+5) is shown in figure.
Grade of concrete : M25 for beams and slabs and M 35 for columns.
The building is situated in earthquake zone III. Assume missing data suitably & should be
clearly indicated. Draft the BMD, SFD & Deflection diagram of AB. Design the beam AB and
column A
DESIGN OF STEEL FRAMED STRUCTURE
Principal rafter : ISA 55x55x6 mm Double angle
Bay width : 4m