Professional Documents
Culture Documents
Pressure switch
RT 113
017R9316
017R9316
cm H2O in H2O
17-273.10
8 3
Danfoss
10 4
1
cm H2O in H2O 12
120 14
2
300
16 6
3
18
250 100
20
8
4
22
80 24
5
200
26 10
6
28
B
C
150 60 30
12
7
e
Exampl 32
40 34
8
100
36 14
9
38
50 20 40
16
10
42
44
0 0
46 18
48
17-5027.10 50
Danfoss
20
mB
10
17-11212.1202
9
Danfoss
6
Example
5
0 A
0,5 1 2 3 4 5 6 m
Installation Indstilling
A set of Pg13.5 cable gland is attached to Fig. 3
DEUTSCH
the RT in a separate bag. To ensure IP66 Daten
(units with automatic reset) or IP54 (units A = Områdeindstilling Abb.1, Abb. 2
with external reset) grade of RT enclosure B = Differens opnået Pressostat Typ RT 113
it is necessary to assemble this gland as C = Differensindstilling
shown in the fig. 2. If this gland is not used Max. Umgebungstempertur 70°C / 158°F
with a cable, a metal blinding should be RT 113 indstilles efter den funktion - slutte eller Max. Prüfdruck: 0.5 bar / 7 psi
also assembled. bryde - som skal ske ved faldende tryk Max. Prüfdruck: 76 cm / 25 in Hg Vakumm
(områdeindstilling). Selve indstillingen udføres Einstellung
Example med håndknappen (5) under samtidig aflæsning Abb. 3
It is desired to control the liquid level in an af hovedskalaen (9). Differensen indstilles med
open-type collecting tank by the use of a suction differensknappen (19) efter nomogrammet i fig. 3. A = Bereichseinstellung
pump and an RT 113 controller. Max. liquid level Højeste funktionstryk er således lig summen af B = Erreichte Differenz
is 130 cm H2O. Differential = 130 - 100 = 30 cm indstillingstryk og differenstryk. C = Differenzeistellung
H2O.
Montering RT 113 is nach der Funktion - Schliessen oder
1. Connect the pump to terminals 1-4 of the Et sæt Pg13,5 kabelforskruning er vedlagt Öffnen - die bei Druckabfall eintreten soll,
pressure switch. produktet i en separat pose. For at sikre einzustellen (Bereichseinstellung).
2. Set the pressure switch for 100 cm H2O by kapslingsgrad IP66 (enheder med automatisk Die Einstellung selbst wird mit dem Einstellknopf
rotating the knob (5). reset) eller IP54 (enheder med ekstern (5) unter gleichzeitiger Ablesung der Hauptskala
3. Set the differential adjusting nut (19) at the DANSK RESET) er det nødvendigt at montere (9) vorgenommen.
figure 7 which is found by reading the denne kabelforskruning som vist i fig. 2. Hvis Die Differenz wird mit der Differezrolle (19) nach
nomogram in fig. 3. denne kabelforskruning ikke bruges sammen dem Nomogramm in Abb. 3 eingestellt. Der
med et kabel, bør der monteres en blindprop obere Ansprechdruck ist also gleich der Summe
Liquid level control in open-type tanks (metal skive). von Einstelldruck und Differenzdruck.
Fig. 4 and 5
Montage
Eksempel Die Kabelverschraubungen PG13,5 sind in
Example 1 Niveauet i en åben opsamlingsbeholder ønskes einem separaten Beutel verpackt. Zum
RT 113 is connected to an air bell, code no. 017- reguleret med en sugepumpe og en RT 113 erreichen des IP66 Schutzgrades (Geräte
401366, through a copper tube, approx. 1⁄4 in. / regulator. Max. væskestand 130 cm H2O. mit automatischen Reset) oder IP54 (Geräte mit
6,5 mm I.D. at minimum liquid level the lower Differens = 130 - 100 = 30 cm H2O. externen Reset) ist eine Montage dieser Ver-
edge of the air bell should be 20 – 40 mm / 3⁄4 –
schraubung notwendig, (siehe Abb. 2.). Wenn
11⁄2 in. below the liquide surface. 1. Tilslut pumpen til pressostatens klemmer 1-4 diese Kabelverschraubung nicht benötigt wird
Maximum liquid temperature: 40 °C / 104 °F 2. Indstil med håndknappen (5) pressostaten på ist ein Metall Blindstopfen zu verwenden.
100 cm H2O.
Example 2 3. Indstil differensknappen (19) på tallet 7, som Beispiel
RT 113 is connected to the tank side immediately fremkommer ved aflæsning af nomogrammet Das niveu in einem offenen Sammelbehälter
over the buttom through a copper tube, approx. i fig. 3. soll mit einer Saugpumpe und einem RT 113
1⁄4 in. I.D., and fittings code no. 993N3572. geregelt werden Max. Niveau 130 und H2O, min.
The minimum horizontal tube length A can Niveauregulering i åbne beholdere Niveau 100 cm H2O. Differenz = 130 - 100 = 30
be read in fig. 6. B is the hight from the tank Fig. 4 and 5 cm H2O.
connection to pressure switch tube connection.
C is maximum liquid level at any time. The tube Eksempel 1 1. Pumpe an die Klemmen 1-4 des Pressostats
section A should be run with a slight upward RT 113 er tilsluttet en luftklokke, best.nr. anschliessen.
gradient towards the pressure switch. In a 017-401366, v.h.a. et kobberrør med 1⁄4 in. indv. 2. Einstellknopf (5) des Pressostats auf 100 cm
narrow space, A can be coiled. Maximum liquid diam. Klokkens underkant skal ved laveste væsk- H2O einstellen.
temperature in the copper tube 40 °C / 104 °F. estand være neddykket 20 – 40 mm / 3⁄4 – 11⁄2 in. 3. Differenzrolle (19) auf die Zahl 7, die sich beim
Ablesen des Nomogramms in Abb. 3 ergibt,
Example 3 Eksempel 2 stellen.
RT 113 is located below the tank. Permissible RT 113 er tilsluttet beholderens side lige over Niveauregelung in offenen Behältern
liquids are raw water, boiler water, sewage with bunden v.h.a. et kobberrør med 1⁄4 in. indv. diam. Abb. 4, Abb. 5