This report summarizes the results of a sieve analysis test conducted on a sample of fine aggregate. The test involves sieving the sample through a series of meshes and calculating the percentage of material retained on each sieve. The results are then checked against specification limits for different construction zones to determine if the aggregate meets the requirements. This sample was found to meet the fineness modulus requirements for Zone I, Zone II, Zone III and Zone IV according to the reference standards cited in the report.
This report summarizes the results of a sieve analysis test conducted on a sample of fine aggregate. The test involves sieving the sample through a series of meshes and calculating the percentage of material retained on each sieve. The results are then checked against specification limits for different construction zones to determine if the aggregate meets the requirements. This sample was found to meet the fineness modulus requirements for Zone I, Zone II, Zone III and Zone IV according to the reference standards cited in the report.
This report summarizes the results of a sieve analysis test conducted on a sample of fine aggregate. The test involves sieving the sample through a series of meshes and calculating the percentage of material retained on each sieve. The results are then checked against specification limits for different construction zones to determine if the aggregate meets the requirements. This sample was found to meet the fineness modulus requirements for Zone I, Zone II, Zone III and Zone IV according to the reference standards cited in the report.
Construction of Central Workshop Building at NRL Site N R L
DATE : REV : Date & Time : ITP NO : REV DATE : REPORT NO : 00 REFERENCE WMS NO: QAP NO : DATE OF RECEIPT : Source : Wt of Sample Taken(gm) A FINE AGGREGATE
WEIGHT ZONE ( AS PER IS 383) REMARKS
SL SIEVE PERCENTAGE CUMULATIVE % FINENESS RETAINED % PASSING NO SIZE RETAINED RETAINED MODULUS (gm) ZONE I ZONE II ZONE III ZONE IV 1 10 mm 100 100 100 100 2 4.75 mm 90-100 90-100 90-100 95-100 3 2.36 mm 60-95 75-100 85-100 95-100 4 1.18 mm 30-70 55-90 75-100 90-100 5 600 µ 15-34 35-59 60-79 80-100 6 300 µ 5 to 20 8 to 30 12 to 40 15-50 7 150 µ 0-10 0-10 0-10 0-15 8 Pan
Reference : Mix-Design Stipulation,IS 2386 Part III,IS 383, Technical Specification/MORTH