Professional Documents
Culture Documents
Exercise 18-3
1. Start Revit 2018
3. Go to Section 1
4. Select all rebar in columns and footings (Hint: use Filter), using Properties,
name the Partition to Parition_1
5. Select all rebar in beam (Hint: use Filter), using Properties, name the Partition
to Parition_2
6. Start Reinforcement Number command, and make sure there are two partition
with numbers from 1-4 for the first, and from 1-3 for the second, and there are
no gaps in the numbering. Click OK to end the command
7. Go to Section A-A
8. Hide the section, and the three reference planes. Click the Crop Region, and
move the bottom part up to show the beam and some of the two columns.
Change the scale of the view to 1:25. Hide the reinforcement of the two
columns
9. Start Linear Multi-Rebar Annotation command; from Properties make sure that
Structural Rebar Section is selected. Select the stirrups at the left and place
the annotation at the bottom of the beam
10. Do the same thing with the middle stirrups and right stirrups
11. Select the left stirrups, and from context tab, select Show First and Last from
Presentation panel. Do the same thing with the other stirrups
12. Start Tag by Category command, and tag the three longitudenal rebars
14. Select all three tags, using Properties change the Type to be Quantity Type &
Number
18-32
Chapter 18: Structural Reinforcement
18. Start Visibility / Graphics command, go to Annotation Categories tab, and turn
off: Grids, Levels, and Sections. Change the Crop Region to fit only the section
21. Start Linear Multi-Rebar Annotation command, from Type change to Structural
Rebar and put the annotation as the below picture suggests. Use the Tag by
Category command to tag the stirrups, then select it and change it to Quantity
Type & Number. You should get the following result:
18-33
Revit Structure 2018 Intermediate and Advanced
24. Add the following parameters: Partition, Rebar Number, Type, Quantity,
Bar Length, Shape, A, B, C, D, E, Total Bar length. Click OK to see the
schedule
27. From Formatting, select Total Bar Length, and make it Calculate totals
28. From Appearance, turn off Blank row before data, and turn on Grid on
headers/footers/spacers
31. Add the Section A-A, Section B-B, and the Rebar Schedule
18-34