Professional Documents
Culture Documents
A Water Meter is a mechanical device to measure the flow rate of a water pump.
[The Water meter comprises a rotor with helical blades inserted axially in the flow, much like a ducted fan; it can be
considered a type of turbine water meter. They are commonly referred to as helix meters, and are popular at larger sizes.]
Installation instructions
• The water meter can be installed in any position • The flow meter must always be filled full
with the direction of the flow as indicated by with water
the arrow cast in the meter body with the
register face upwards • The flow meter must be protected against
pressure shocks in the pipe
• Thoroughly flush the pipes before
installing the meter • The pipe pressure and water temperature
must not exceed the values shown on the
• It is important that you observe the required type plate
calming section (see below)
• All flow control components (e.g. valves)
• If the water is soiled, fit a strainer in the should be installed after the flow meter
pipe before the meter
V14110
6
All specifications and information are given with good intent, errors are possible and products may be subject to change without notice.
Pictures may differ from actual products depending on local market requirements and regulations.
Water Meter
Calming sections
The water meter must have 10 nominal diameters straight pipe ahead of the meter and 5 nominal
diameters straight pipe after to insure a correct flow measurement.
Technical Data
Nominal Diameter DN 40 65 80 100 125 150 200
Maximum flow rate m³/h Q_max 20 50 80 120 200 300 500
Nominal flow rate m³/h Q_n 10 25 40 60 100 150 250
Transition flow rate m³/h Q_t 3.0 5.0 8,0 12 20 30 50
Minimum flow rate m³/h Q_min 0.7 0.75 1.2 1.8 3.0 4.5 7.5
Maximum reading m³ 999999.999 9999999.99
Minimum reading m³ 0.001 0.001 0.001 0.001 0.001 0.01 0.1
V14110
6
All specifications and information are given with good intent, errors are possible and products may be subject to change without notice.
Pictures may differ from actual products depending on local market requirements and regulations.
Water Meter
Dimensions
Accuracy Curve
V14110
6
All specifications and information are given with good intent, errors are possible and products may be subject to change without notice.
Pictures may differ from actual products depending on local market requirements and regulations.
Water Meter
The Accuracy Curve shows the imprecision in percent for different flow rates. In regular operation
the deviation is between -2% and +2%.
- It is a turbine Removable Element water meter for industrial and irrigation application in size
40mm to 150mm for cold meter
- The special version WP-40 ~ 150 water meter is equipped with a reed switch assembly which
can be connected to remote reading systems after breaking the meter seal.
- The reed switch pulser sends out electrical signals per a preset water quantity requiring
power from an external source
Working Conditions
Working conditions, dimensions and technical data are the same as the common water meter
Electric Data
- The special meter comes in two model variations, which indicate different pulse rates
- To choose the variation best suited to your needs, please consult the table below.
V14110
6
All specifications and information are given with good intent, errors are possible and products may be subject to change without notice.
Pictures may differ from actual products depending on local market requirements and regulations.