Professional Documents
Culture Documents
EXPERIMENT NO: 02
EXPERIMENT NAME: Implementation Of 2D Drawing.
DATE OF PERFORMANCE: 21.10.2019
DATE OF SUBMISSION: 28.10.2019
SUBMITTED BY:
SUBMITTED TO:
Name:
Md.Ansarul Islam
Designation: Lecturer
Department of CSE
Green University of Bangladesh
Experiments Tools:
1.Autocad 2018.
2.Desktop PC.
Experments Discription
1.AutoCad Page Setup:
For page setup we need to set units which is in the Formate tool.
First press Formate Press Units Then we need to set the setting by
Length: Architectural0-0
Angle:Decimal Degrees0.0
Insertion Scale: Unit to scale inserted content: Inches.
2.Gird & Snap :
We used Gird And Snap to specify the correct from of an object.Gird and
snap makes a drawing item exactly as it has to be seen.
Gird: In the lower right bar we can see a icon like this (#) from there we can turn on
the GRID mode. Moreover,we can also use the (f7) button to turn on the GRID mode
.Grid helps us to create object using points.(Layout 2)
Snap: At the side of the gridline button we see a button called SNAP from there we
can turn on the SNAP mode. Snap helps us to create an object by using gridline
points only without any interruption.(Layout 2)
3.SPLine :
A SPline is a smooth curve that passes through or near a set of points that
influence the shape of the curve. SPLINE creates curves called nonuniform
rational B-splines referred to as splines for simplicity.
In the upper left corner we find the DRAW option from there we could draw a spline.
Process:
DRAWSPLINEDraw a curve.
4.Polygon(Inscribed & Circumscribed):
Polygon(Inscribed) : An inscribed polygon is a polygon in which all vertices lie on a
circle.The polygon is inscribed in the circle and the circle is circumscribed about
the polygon.