Professional Documents
Culture Documents
API-2W grade 50 high yield structural plates are intended for (but not limited to) use in fixed offshore structures, designed to
operate in the offshore sector.
API 2W steels are intended for t ≤ 25 mm 345 - 517 MPa Sulphur content is controlled. Through thickness testing when
fabrication primarily by cold forming 25 < t ≤ 40 mm 345 - 483 MPa called for via option S4.
and welding. 40 < t ≤ 63 mm 345 - 483 MPa Heat analysis for Sulphur shall Min Tensile 358 MPa
63 < t ≤ 80 mm 345 - 483 MPa be max 0,006% when specified (=80% of 448 MPa).
80 < t ≤100 mm 345 - 483 MPa via option S5. TTP testing is not
mandatory. This should be
specified via option S4.
The primary use of these steels is in tubular joints, stiffened plate construction and other intersections where portions of the plate will be subject to tension in the
thickness direction. Supplementary requirement S4 provides for through-thickness testing of plates and specifies limits for acceptance. This steel offers enhanced
through thickness ductility and impact values verified at minus -40°C.
Chemical composition
Product analysis in % (All values are max. unless otherwise stated.)
t ≤ 40 mm: 0,22
Pcm
S 0,006 V - 40 <t ≤ 90 mm: 0,23
see formula below 40< t ≤ 150 mm: 0,24
Cr 0,25 As3 -
Mo 0,08 Sb - Bi -
Ni 0,75 Sn - Ca -
Al4
0,015/0,055 Pb - B3
0,0005
Surface
All surfaces have been 100% visually inspected. The surface condition does comply with EN 10163-2, class A, sub-class 3.