Professional Documents
Culture Documents
Power Train
Systems Operation Section
g00928752
Illustration 31
38
Power Train
Troubleshooting Section
Troubleshooting Section
Check valves in the hydraulic system may allow
pressure to exist in the hydraulic lines after the en-
Introduction gine has been stopped. Pressure must be relieved
prior to servicing the components of the hydraulic
i01792901 system. Failure to relieve pressure prior to servic-
ing may result in personal injury.
General Information
SMCS Code: 4800 1. Move the machine to a smooth horizontal
location. Move away from operating machines
Visual checks are the first steps in order to and move away from all personnel. Lower all
troubleshoot a problem. When the visual inspections implements to the ground. If equipped, place
are complete and the problem is not fully the control lever for the blade lift control valve
understood, perform operational checks. After visual in the FLOAT position.
inspections and operation checks are complete
and the problem is not fully understood, perform 2. Install the wheel lean locking bolt in the front
test procedures. These procedures will help identify axle. Install the frame lock pin. Engage the
system problems. These procedures are located in parking brake and stop the engine.
the Testing and Adjusting module for your machine.
3. Permit only one operator on the machine. Keep
For the locations of your individual system all other personnel away from the machine. Also,
components, refer to the Systems Operation module all personnel should be visible to the operator.
for your machine.
4. Place chocks in front of the wheels and behind
For more information on the electrical system, refer the wheels.
to the Electrical Schematic for your machine.
5. Carefully loosen the filler cap on the hydraulic
For more information on the hydraulic system, refer tank in order to release the pressure in the tank.
to the Hydraulic Schematic for your machine.
6. Make sure that all hydraulic pressure is released
before you perform any of the following
i01792733 procedures: