Professional Documents
Culture Documents
Instruction: Answer FIVE FULL questions, choosing one from each unit.
UNIT-1
1. a) Analyze and sketch the following the signal operation shown in figure.1: 10
i).x(t-2); ii).x(-t-2); iii).dx(t)/dt ; iv) .sgn(t)x(t); v).x(t/2).
x(t)
1
-3 3 4
-t +t
-2 -1 0 1 2
-1
Figure.1
b) Analyze and sketch the even and odd signals shown in figure.1: 05
c) Analyze and check whether the signal are power or Energy and find its energy or 05
power for the signal shown in figure 1
UNIT-2
2. a) Analyze and develop the CT convolution integral of the signal h(t)=u(t)-u(t-3) and 08
x(t)= u(t)-u(t-1).
3. a) Design an LTI system, which results in response y(n), if the input sequence x(n)=u(n)- 08
u(n-3) and h(n)=[1 3 2 -1 1 ] by graphical method. Verify the response of the system
using short cut method.
UNIT-3
4. a) For the function x(t) given below, analyze the signal and estimate the Exponential 08
Fourier series and also Sketch the magnitude and phase spectrum.
( ) ( ) ( )
n n1 3n 06
Consider the DT signal x(n) 4 2 cos cos cos .
b) 4 2 4 4
Analyze and sketch its power density spectrum.
c) Explain the sampling theorem with various types of spectrums for low pass signals. 06
UNIT-4
5. a) Develop an expression for transfer function and evaluate the Fourier Transform system 08
shown in figure.2. Analyze and sketch magnitude and Phase spectrum.
C
O/P=v2(t)
R
I/P=v1(t)
Figure.2
c) Evaluate the Laplace transform and the associated ROC for following functions. 06
a).x(t)=e-2tu(t) + e-3tu(t) b) x(t)=e-5t[ u(t)-u(t-5)]
UNIT-5
6. a) List out the properties for the ROC (Region of convergence)of Z-transform. 06
b) Apply the knowledge of properties of Z-Transform and Evaluate the Z-Transform & 06
its ROC.
i) .x(n)= nan-1u(n);
iii) ( ) * ( ) ( )+
iii) ( ) ⌈( ) ( )⌉
OR
7. a) Apply the knowledge of properties of Z-Transform and Evaluate the Z-Transform & 08
its ROC:
) ( ) * + ( ) ) ( ) ( )
b) Prove that the sequences: i). x1 (n) a n u(n);&ii ).x2 (n) a n u(n 1) have the same X(z) 05
and differ only in ROC, Also plot their ROC’s.
c) Analyze and mention which of the following method is better in finding initial and 07
final value ( ) using
( )( )
i). Inverse Z-transform; ii). Initial and final value theorems.
*******