Professional Documents
Culture Documents
Bu 76
Bu 76
a. house sewer
b. house trap
c. house drain
2. The developed length of a water closet trap arm, measured from its floor flange to to inner edge of its vent,
should not be more than _____ feet.
a. 6 feet
b. 8 feet
c. 10 feet
d. 12 feet
3. A vertical pipe that doesn't carry any waste and its main purpose is to regulate air
pressure throughout the plumbing system; usually runs parallel with the soil or
waste stack and extend up through the roof or connect to a soil stack extension above
the highest horizontal soil branch pipe.
a. branch vent pipe
c. vent stack
d. stack vent
c. Within 15.00 meters inside the property line before the house sewer connection
a. bar sink
b. lavatory
c. bath tub
d. kitchen sink
a. lavatory
b. water closet
c. service sink
d. bath tub
7. If the horizontal drain piping of a residence has a run of 10 meters, what will be its dip toward the point of
disposal.
a. 100mm
b. 200mm
c. 300mm
d. 400mm
8. This type residential storm drainage system requires the digging of deep ditches and
the installation of underground perforated pipes.
a. downspout and gutter drainage system
a. trap seal
b. plumbing trap
c. pipe plug
d. pipe clean-out
10. Drain pipes for refrigerators and other equipment for food-storage purposes shall have a size of not less than
______mm for one unit.
a. 25mm
b. 32mm
c. 38mm
d. 50mm
11. What type of vent is permitted for a group of plumbing fixtures on the same floor, but not between floors?
a. branch vent
b. direct vent
c. wet vent
d. common vent
12. A receptacle installed to retain storm water for a sufficient period to allow materials to settle and be deposited.
a. splash block
b. area drain
c. catch basin
d. gutter
13. A gully trap, connected to the waste drainage system, is provided for this method of plumbing system.; the soil
and wastewater do not combine until they reach the below-ground drainpipes.
a. partially-ventilated one-pipe system
b. one-pipe system
c. two-pipe system
a. 200mm
b. 400mm
c. 600mm
d. 800mm
15. This method of plumbing system is comprised of only one soil pipe and a relief vent pipe; the vent pipe
diameter should not be less than 50mm and the traps should have deep water seals of not less than 75mm.
b. one-pipe system
c. two-pipe system
16. A common residential drainage system that carries away storm water from the roof down to ground.
17. Plumbing trap seals are broken when a large amount of waste flows into the drainage system compressing the air
in front of it. What causes this break of the trap seal?
a. trap siphonage
b. back pressure
c. evaporation
d. capillary action
18. Sanitary wastes are excluded from this drainage sub-system as it only conveys water from
cooling equipment, ground, surface run-off and sub-surface, up to the point of disposal.
a. soil drainage system
d. vent system
19. If the roof is used other than for weather protection, extensions of soil and waste stacks shall not be less than
________ meters from the roof level
a. 1.20 meters
b. 1.80 meters
c. 2.40 meters
d. 3.00 meters
20. It is a type of sewage system disposal that has a hole in the ground lined with stones, bricks, or concrete hollow
blocks laid in a manner as to allow raw contaminated sewage to leach into the soil; the organic wastes are disposed
of by disintegration process.
a. privy
b. cesspool
c. septic tank
d. sewer line
21. If the diameter of a fixture trap arm is 32mm, what is the minimum distance of the trap weir from the fixture
vent?
c. stack vent
d. vent stack
23. The minimum required size of a plumbing trap for three fixtures of similar functions.
a. 25mm
b. 32mm
c. 38mm
d. 50mm
24. Double bowl kitchen sinks, triple compartment sinks and laundry sinks can have one plumbing trap so long as
the compartments must be next to one another and each compartment cannot be spaced more than ___ inches apart
center to center of the drains.
a. 18 inches
b. 24 inches
c. 30 inches
d. 36 inches
25. All of these fittings are prohibited when connecting a vertical waste pipe to a horizontal waste pipe, except one.
b. double hub
b. one-pipe system
c. two-pipe system
27. A maximum allowable vertical drop from the fixture outlet for sinks, lavatories,
showers and bathtubs to the water seal should not be more than ______ mm.
a. 300mm
b. 450mm
c. 600mm
d. 750mm
28. A type of residential drainage system that contain shallow ditches dug in a parallel
pattern, which act as canals for run-off water.
a. downspout-and-gutter drainage system
29. This type of vent is on the highest branch interval; typically does not require a relief vent, and connects to the
stack vent and not to the vent stack.
a. branch vent
b. wet vent
c. circuit vent
d. loop vent
30. Where a fixture or trap cannot be properly vented, what type of plumbing trap would be ideal in cases such as
these?
b. drum trap
c. crown-vented trap
d. S-trap
31. If the drain for a steam cooker of a commercial kitchen is 50mm, what should be the minimum distance
required for the air break?
a. 25mm
b. 32mm
c. 38mm
d. 50mm
32. What is the maximum number of plumbing fixtures that a circuit or loop vent can serve or ventilate?
a. 10 fixtures
b. 8 fixtures
c. 6 fixtures
d. 4 fixtures
33. The following are the variables used for sizing the stack vents and vent stacks, EXCEPT ONE.
b. wet vent
c. circuit vent
d. loop vent
37. What is the recommended receptacle to handle storm water in an open ground?
a. splash
block
b. catch basin
c. area drain
d. gutter
38. This type of residential drainage system is best recommended for areas that have grades.
a. 25mm
b. 32mm
c. 38mm
d. 50mm
40. All roof extensions of soil and waste stacks shall be run full size at least ____ millimeters above the roof.
a. 100mm
b. 200mm
c. 300mm
d. 400mm
41. What type of pipe fitting is used to connect a sink or lavatory to a vertical waste pipe?
a. tap tee
b. double tee
c. wye fitting
42. This type of sewage disposal system does not have a leach or French drains as the effluent is carried by large
pipes to a lagoon.
d. vent system
44. The trap seal depth is measured from the trap dip to the ____________.
45. The trap seal depth is measured from the trap dip to the ____________.
46.