Professional Documents
Culture Documents
Inspection
1 Introduction
Thank you for purchasing SCUDO product. This series is designed to automatically
Remove the unit from the shipping package and inspect it for damage
that may occurred during transportation. Notify the carrier and place
of purchase if any damage is found.
maintain a constant voltage level to protect sensitive electronics from brownouts
and overvoltages. With its fashionable and flexible cabinet, it can be installed on a Placement & Storage Conditions
desk or wall without causing an unsightly or unprofessional image, and will perfectly Install the unit in a protected area that is free of excessive dust and has adequate
utilize a limited working environment. This series offers one-step boost and one-step air flow. Please place the UPS away from other units at least 2.5cm to avoid
buck stabilizer to continuously supply a clean power source to its connected equipment. interference. Do NOT block the top or side air vents on the unit.
2 Product Overview
1
2.5cm
(1 inch)
Before using the product, please be sure that Power LED is on. If the Power LED is
To safely operate this voltage regulator, please read and follow all not on, please check the following steps:
instructions carefully. Read this manual thoroughly before attempting to
1. Check if the mains is normal.
unpack, install, or operate. You may keep this quick guide for further
reference. 2. Check if the power cord is connected firmly.
3. Check if the connected devices are connected to the unit firmly.
CAUTION: The unit is designed only for use under the 50 Hz input frequency and
4. Check if the unit is turned on.
pure sine wave environment. Any other input frequency or wave form will effect the
voltage range and load capability. Use the below table to solve the minor problems.
CAUTION: Please DO NOT connect the unit to the environment with direct voltage Problem Possible Cause Solutions
or simulated sine wave. Circuit breaker The unit is overload. Remove some loads
is “tripped”. first. Reset the circuit
CAUTION! To prevent the risk of fire or electric shock, install in a temperature and breaker by pressing the
humidity controlled indoor area free of conductive contaminants. (See the button again.
specifications for the acceptable temperature and humidity range.)
The unit is The unit is over- Remove some loads and
turned off heated. It’s internal wait until the unit is cool.
automatically protected function. Then turn on the unit
CAUTION: The total power consumption of all equipment plugged into the If any abnormal situations occur that are not listed above, please call
voltage regulator must not exceed its capacity*. A total load in excess service people immediately.
of its capacity* will cause the fuse to fault (blow).
The voltage regulator is designed for use with voltage sensitive equipment
7 Specifications
such as: a home computer, monitor, inkjet printer, scanner or fax. It is also Model 600 1000 1200
designed for use with home electronics equipment such as television, CAPACITY 600 VA / 360 W 1000 VA / 600 W 1200 VA / 720 W
stereos, CD players, VCRs, and DVD players, data processing equipment, INPUT
modems, typewriters, calculators, and telephone equipment. Voltage 220 VAC
Voltage Range 180 - 264 VAC
Appliances not suitable for use with the product are items such as freezers, Frequency 50 Hz
power tools, air conditioners, dehumidifiers, blenders, or any device that OUTPUT
employs an AC motor for operation. Not for use with small fuel generators. Voltage Regulation +/-12%
Also excluded are life sustaining equipment. AVR +/- 8%
INDICATORS
When use the voltage regulator with an Interruptible Power Supply (UPS), Power LED Green lighting
connect the UPS to the output of this product, then connect the product AVR LED Red lighting
to the wall outlet. PROTECTION
Comprehensive Short circuit, overload, and over-temperature
Protection protection
PHYSICAL
Dimension (DxWxH mm) 166 x 161 x 86.7
Net Weight (kgs) 1.7 2.0 2.1
ENVIRONMENT
Humidity 0-90 % RH @ 0-40 C (non-condensing)
Nosie Level Less than 40 dB