Professional Documents
Culture Documents
1. TRACK LINK
1) REMOVAL
(1) Move track link until master pin is over
Master pin
front idler in the position put wooden
block as shown.
(2) Loosen tension of the track link.
ż If track tension is not relieved when the
grease valve is loosened, move the
machine backwards and forwards.
2) INSTALL
(1) Carry out installation in the reverse order
to removal.
ż Adjust the tension of the track link.
90-110Ş
8-142
2. CARRIER ROLLER Frame
1) REMOVAL
Grease
(1) Loosen tension of the track link.
valve
2) INSTALL
(1) Carry out installation in the reverse order
to removal.
8-143
3. TRACK ROLLER Frame
1) REMOVAL
(1) Loosen tension of the track link. Grease
valve
2) INSTALL
(1) Carry out installation in the reverse order
to removal.
8-144
4. IDLER AND RECOIL SPRING
1) REMOVAL
(1) Remove the track link.
For detail, see REMOVAL OF TRACK LINK
2,3
2) INSTALL
(1) Carry out installation in the reverse order
to removal.
ż Make sure that the boss on the end face
of the recoil cylinder rod is in the hole of
the track frame.
8-145
3) DISASSEMBLY AND ASSEMBLY OF IDLER
(1) Structure
7
6
4
3
5
1 2
2
5
4
7
8-146
(2) Disassembly Press
ڸRemove plug and drain oil.
ڹDraw out the spring pin(7), using a
press.
8-147
(3) Assembly
ż Before assembly, clean the parts. Press
1 2
ż Coat the sliding surfaces of all parts
with oil.
ڸCool up bushing(2) fully by some dry
ice and press it into idler(1).
Do not press it at the normal temperature,
or not knock in with a hammer even
after the cooling.
8-148
ڽInstall bracket(6) attached with seal(5).
6
8-149
4) DISASSEMBLY AND ASSEMBLY OF RECOIL SPRING
(1) Structure
4 7 8 6 5 4 2 1 9 10 11 12
13
8-150
(2) Disassembly
Press
ڸApply pressure on spring(3) with a 4
press. 7
ż The spring is under a large installed
load. This is dangerous, so be sure to 8
set properly. 6
Spring set load : 8497Ź 680 5
'18732Ź 1499(
3
ڹRemove bolt(7), spring washer(8) and
plate(6).
ںRemove lock nut(5).
Take enough notice so that the press
which pushes down the spring, should
not be slipped out in its operation.
ڻLighten the press load slowly, and
remove bracket(4) and spring(3).
13
8-151
(3) Assembly
ڸInstall rod packing(11), back up 1 9 10 11
ring(10) and dust seal(9)to body(1).
ż When installing packing(11) and seal
(9), take full care so as not to damage
the lip.
8-152
ڽLighten the press load and confirm the
Press
set length of spring(3). 7
ھAfter the setting of spring(3), install 8
plate(6), spring washer(8) and bolt(7). 6
5
3
405
8-153