Professional Documents
Culture Documents
AREA STATEMENT
EXTERIOR CIRCULATION
• There are two different gates for entry and exit.
• The pavements on the side of the building are
• 5m wide.
• the main approach is through national highway 95.
• Ramp: Provision of ramps is given to park the vehicles in all the basements.
• Width 2500mm Slope 1:10 Basement parking:
• Provision of parking for the visitors is provided in the basement.
• To approach the basement parking ramps have been provided.
• Three basements cater the parking.
VERTICAL CIRCULATION
• Escalator at each floor serve for vertical circulation.
• 2 public staircase at each floor.
• Along with 2 lifts and 1 service lift 5 service staircase at lower ground floor which
reduces to 1 at other levels.
• 4 exit staircases from the cinema Opens at second floor
LIGHTING
Both natural and artificial lightings are provided to illuminate the interiors of the mall:
Natural Lighting:
• Natural light in the interiors is received through the sunlight.
• Central courtyard is well lighted with the indirect sun light by cutting the direct
glare with the sheet on top.
• The courtyard is well lighted with daylight in
• the day time, which gives feeling ofopenness.
Artificial Lighting:
• By the night time, interior enhances due to its lighting effects.
• Well lighted atrium with natural light.
Anchor store
Retail store
FIRST FLOOR
• The first floor boast men’s wear brands. On the second floor, women wear
and kids wear are available. A spa, health club, an entertainment centre for
kids and many other attractions that are seen in the mall.
• Covered area = 53831 sq.Ft
SECOND FLOOR
•The grandeur of the mall is well set in the plethora of its huge atrium with a floating
bridge café
– A unique feature of the mall.
•It incorporates 48 retail shops of varying areas .
• Covered area =55369 sq.Ft
ELECTRICAL SERVICES
• Whole electricity control is through electrical room in third basement.
• Generator provision is there in the third basement too.
• Two transformers of 2500 kva is installed in third basement.
• Design of the complete distribution system is such that maximum voltage drop at the
farthest point from the transformers is restricted to 5% which is in compliance with the Water pipe going on through basement and is
Indian electricity rule. getting supply By pump room in basement
• The lt distribution scheme is such that there is a electrical room at each floor where the
floor distribution is located. floor distribution panel to the load center at each zone of the
floor is fed with the help of small distribution board.
• Electricity equipment's getting controlled through electricity room in basement
AIR CONDITIONING
• Air conditioning control is also through the third basement itself.
• Air conditioning ducts are running throughout the basements.
• Air conditioning piping is going through the slabs.
• Main plant consists of 4 nos. water cooled screw chiller, 3 nos. chilled water pumps
(one standby), 3 nos. condenser water pumps (one standby) along with 6 nos.
cooling tower (one standby).
• Main plant is located at terrace with a total tonnage refrigeration of 1600 tonnes and
chilled water from the main plant is supplied to air handling units located at various
floors.
• Air conditioning duct on all floors Air conditioning duct running
throughout The basement
FIRE HYDRANTS:
• Wet risers shall be tapped from ring main and run along the
shaft.
FIRE EXTINGUISHERS:
• Portable type class A,B&C fire extinguishers are provided at all fire sensitive
places.
• In Basements the water curtains are made according to zones which activate
automatically in case of fire. Also these prevent smoke & fire to spread from one
zone to another.
SIGNAGES
• Approximately 350 signages were
designed
• After going through the tedious
process of devising a system to
create standaredised signage panels,
and get the locations, size and the
content for each signage panel right.
• Wide ramps along with stairs and handicapped friendly conveniences, well equipped with requisite
utilities have been provided for physically challenged Patrons, Patrons with temporary disability of
mobility and Senior Citizens visiting the Mall and/or the Cinemas.
• The Mall has installed Sewerage Treatment Plant of the latest technology whereby it can convert the
sewerage into soft water and the treated water can be used to meet air-conditioning requirement and
horticultural purpose. It is also equipped with Rain Water Harvesting system.
• Further, the Mall is equipped with state-of-the-art security systems and latest technology in fire
safety measures have been adopted for fire detection and fire fighting in the Mall, as the Group
believes in not compromising with humansafety and security.
• Two of the floors at the Mall are specially dedicated to Food Court and Fine Dining restaurants where
the patrons can enjoy variety of Indian and International authentic cuisines.
• The Mall also houses Spa and gaming zone for children.
• The grandeur of the Mall is well set in the plethora of its huge Atrium with a floating bridge café – a
unique feature of the Mall. The plush Atrium is articulately surrounded by extensive corridors leading
way to the numerous national and international brands who have eagerly taken up space at the
vivacious Mall.