Professional Documents
Culture Documents
NOTE
1. Only qualified personnel are allowed to install the antennas and MMIK000103.
2. The appearance of the antennas or MMIK000103 shown in the figures is only for reference and may differ from the actual one.
CAUTION
Torque wrench
40 N·m
*09310438981X200117HW* 1 Copyright © Huawei Technologies Co., Ltd. 2020. All rights reserved.
MMIK000103 Installation Guide
Part Number: 31043898 Issue: 02
NOTE
4. Install the clamp on the pole, and partially tighten the bolts.
NOTE
The clamp must be first installed on the MMIK000103, and then installed
on the pole with the MMIK000103. If the clamp is first installed on the
pole, the mounting holes of the MMIK000103 may be misaligned.
a Loosen the bolt and nut, as shown in the following figure. b Adjust the height and horizontal angle of the
MMIK000103 to ensure that the sliding
blocks on both sides can be fastened to the
passive antenna cover.
10 N·m
40 N·M
1. Cut off the cable ties at the bottom of MMIK000103 and remove
the rear cover of the MMIK000103.
M4
M6
NOTE
If the rear cover of the MMIK000103 has been removed under the
tower, skip this step.
a Loosen screws. b Adjust the rope and slowly put down the MMIK000103 cover.
M6
3. Install the Massive MIMO on the pole. For details about how to install an Massive MIMO , see
the installation guide for the corresponding model.
NOTE
1. The Massive MIMO should be far away from the passive 2. The distance between the upper and lower brackets of
antenna so that there is enough space for installing the Massive the Massive MIMO should be no larger than 850 mm.
MIMO cables. In addition, the distance between the Massive
MIMO clamps and MMIK000103 clamps should be no less than
50 mm.
L2
L1
L2 < 850 mm
L1 > 50 mm
M6
5. Secure the rope to the brackets of the MMIK000103 using cable ties.
Appendix
F Bracket
D Bracket
Unit: mm