Professional Documents
Culture Documents
A. B. C. D.: Caav Question Bank - A320/321-Level A
A. B. C. D.: Caav Question Bank - A320/321-Level A
7. How many points on the structure are designated for the purpose of lifting the
aircraft?
A. 3
B. 4
C. 2
B. The weight of fuel is applied equally on the two side of the aircraft centerline
C. Make sure that the aircraft is stable before you lift it with jacks
D. All above
17. The maximum permitted steering-angle on each side of the aircraft centerline is
A. 95 degrees.
B. 75 degrees.
C. 74 degrees.
C. VHF only.
20. What indication on ECAM do you have to check prior to start towing?
A. N WHEEL STEERG DISC
B. N WHEEL STEERG INOP
C. N WHEEL STEERG OFF
21. From cockpit how can you know that the brake are release prior to towing the
aircraft?
A. Check Parking brake selector in OFF, brake pressure indication on ECAM is at 0
and confirm with GND personnel.
B. Check Parking brake selector in OFF; check all the 03 pointes are at green range
and confirm with GND personnel.
C. Check Parking brake selector in OFF; brake pressure pointes at 0 and confirm
with GND personnel.
22. Minimum separation from the nose wheels and the tractor while towing the
aircraft is:
A. 2 m
B. 3 m.
C. 4 m.
23. In towing configurations the safety pin locks the control lever on the interphone
box in:
A. Disengaged position.
B. Engaged position.
C. Normal position.
ATA12 SERVICING
25. When you do the Aircraft Grounding for the Refuel/Defuel Operations
A. Connect the ground cable to parking ground point before you connect it to the
aircraft
B. Attach the cable to aircraft first then connect to parking ground point
C. Grounding is not necessary
A. Do not operate the cell phones or mobile phones inside distances for 6m from
aircraft.
B. Do not connect electrical equipment to a power source less than 15 m away from
aircraft, unless the power source has spark-proof connectors
C. Do not operate the fuel tanker/pump unit until you stop operation of the weather
radar
D. All above
32. When you do the aircraft pressure Automatic refueling with battery power
A. It is not always possible to refuel to full capacity. This is because the intercell
transfer valve are not always in the correct position
B. It is always possible to refuel to full capacity.
C. You can not refuel in the outer cell.
35. When you do the aircraft pressure refueling with manual control
36. The aircraft configuration requirements for filling the hydraulic fluid reservoir
are:
A. The FWD, AFT cargo-compartment doors and the landing gear doors are closed
B. The FWD, AFT cargo-compartment doors and the landing gear doors are opened
C. The FWD, AFT cargo-compartment doors are closed and the landing gear doors
are opened
D. The FWD, AFT cargo-compartment doors are opened and the landing gear doors
are closed
38. What happen if you fill to much hydraulic fluid in the reservoir?
A. Hydraulic system can not operate
B. A message "reservoir overfull" appear on ECAM
C. You cannot pressurize it the reservoir sufficiently and may cause the message
"RSVR LO AIR PR" on ECAM.
D. Hydraulic fluid transfers to other reservoir.
39.When filling the hydraulic fluid Reservoir with a hydraulic service cart, the
maximum supply pressure is:
A. 3.5 +0.3 -0 bar (50.7631 +4.3511 -0.0000 psi)
B. 30 bar (435,1132 psi).
C. 45 bar (652,669 psi)
D. 50 bar (725,188 psi)
40. If you think there are fuel fumes when you remove the oil filter cap of the engine
oil tank.
A. You must let the oil tank pressure bleed off for a minimum of 5 minutes before you
remove the tank filler cap for oil servicing.
B. Add oil in the oil tank to full mark
C. Replace the fuel/oil heat exchanger then flush the engine oil system
D. Flush the oil tank and fill in with new oil.
46. What is the main purpose of the pack anti ice valve?
A. To stop the ice formation across the primary heat exchanger.
B. To stop the ice formation across the main heat exchanger.
C. To stop the ice formation across pack condenser.
48. What flow is delivered by pack with Pack Flow selector on LO and bleed air
supplied by the APU?
a. Low
b. Normal
c. High
50. When does the avionics ventilation air come from when any OVRD selected?
A. From the avionics bay
B. From outside the aircraft
C. From the air conditioning duct
D. No ventilation. System is inoperative.
51. What is the purpose of the avionic ventilation skin heat exchanger?
A. To cool the air coming from the avionics equipment when Isolation valve is open.
B. To reheat air coming from avionics ventilation system
C. To cool air before it is ducted under the cargo compartment.
42.Aircraft on ground, in order to communicate from the cockpit to the APU position,
you must:
A. Select the INT on the audio control panel, and press the “SERV INT” pushbutton
B. press “CAB” transmission key
C. press the “SERV INT” pushbutton
D. press “CAB” receiving knob
45. Both light “AVAIL” and “NOT IN USE” in the external power receptacle are
illuminated when:
A. An External Power Source is supplying the Aircraft Network
B. An External Power Source is supplying the Maintenance Bus Bars
C. At least one External Power Parameter is not correct, the External Power Contactor
(EPC) stays Open
D. All External Power Parameters are correct but the EPC is Open
A. An immediate APU shut down is commanded and the APU Generator is denergized
B. The APU Generator is disconnected only
C. The APU Generator Fault Light illuminates only
D. A Warning Message is displayed on ECAM only
47. What does the EXT PWR PB “AVAIL” light illuminated on EXT PWR panel
means?
A. External power is plugged in,and all parameters are normal
B. All external power parameters are normal but not plugged in
C. External power is plugged in
D. External power is plugged in and supplied to A/C network
ATA25: FURNISHING
49. Smoke hoods are supplied for the cabin attendants to:
A. Supply oxygen for passengers.
B. Fight a fire or against emission of smoke or noxious gases.
C. Breathe oxygen.
50. Which device has to be unlocked before closing the slide window?
A. A locking pin on the sliding window frame.
B. The sliding window operating handle.
C. None.
54. Captain and First Officer Seats electrical control system permits
A. Control the seats in vertical and horizontal direction
B. Control the seats in vertical and horizontal direction and adjust the backrest
C. Control the seats in vertical and horizontal direction and adjust the lumbar rest
D. All above
55. The A320 aircraft is fitted with emergency evacuation slide at:
A. The 4 entry doors.
B. The overwing exits
C. The 4 entry doors and the overwing exits
62. You press the APU shut off push button at 108VU panel to?
A. Initiate the shut down the APU with cooling down sequence.
B. Initiate the emergency shut down of APU without cooling down sequence.
C. Initiate the emergency shut down of APU and discharge the APU fire bottle.
64. What additional external warning is/ are activated in case of APU fire on
GROUND?
A. APU fire light & external horn warning.
B. A fire bell warning.
C. An external horn warning only.
D. An external horn warning & Red disk indicator disappears.
65.How many fire extinguishing bottle(s) is(are) provided for the cargo
compartments?
A. There’s one for FWD and one for AFT cargo compartment.
B. There’s one for both FWD and AFT cargo compartments.
C. None.
69.When the center tank is empty, in auto mode, center tank pumps:
A. Must be manually switched OFF
B. Stop and wing tank pumps start running
C. Stop automatically
D. Run for 2 minutes
72.What is the maximum total fuel capacity for VNA’s A320 aircraft?
A. 12 470 KG
B. 15 588 KG
C. 18 932 KG
D. 20 829 KG
78.When performing the refuel, defuel, Ground transfer, the R/D electrical circuit is
enable by?
A. Power from the aircraft electrical net work only.
B. Carrying out HI LVL test.
C. Contact R/D panel door switch.
ATA-29 HYDRAULIC:
79.In flight, if the blue electric pump fails the blue system:
A. Is lost.
B. Can be recovered by the RAT.
C. Can be recovered by the PTU.
D. Both B and C.
81.To which system(s) will the Ram Air Turbine provide hydraulic power?
99.Can the crew oxygen cylinder pressure be checked when there is no electrical
power?
A. Yes
B. No
101.At high engine speed the high pressure valve (HPV) is:
A. Regulating a pressure
B. Fully closed
C. Fully open
D. Regulating a temperature
102.Where the air is taken from during engine high power setting?
A. IP stage.
B. HP stage.
C. IP and HP at the same time.
106.Which signal close the Fill/ Drain valve during servicing with electrical power
available?
A. By a quantity transmitter which sends a tank full signal to close the fill/drain valve
automatically
B. When the quantity gauge indicates full the valve has to be closed manually
C. When the water comes out of the overflow port the valve has to be closed manually
D. There is no signal available, the tank has to be filled with a measured amount of
water.
109.Is it possible to drain the whole water system without electrical power?
A. No, electrical power is always required
B. Yes, all the drain valves can be operated manually
C. No, only the water tanks can be drained by using the aft drain valve
D. No, only the forward drain valve can be operated manually.
112.How many valves are used during draining operation of A320 aircraft water tank
A. Two
B. Three
C. Four
113.How many potable water service and drain panels are fitted to the A320 aircraft?
A. One
B. Two
C. Three
114.Where is the main drain port of the A320 aircraft potable water system?
A. On the portable water service panel.
B. On the fwd service panel.
C. Both
121.How many potable water service and drain panels are fitted to the aircraft?
A. One
B. Two
C. Three
ATA 49 - APU.
130.The high oil temperature or low oil pressure detected during APU operation, the
ECB will cause the APU to shut down:
A. Only if the MASTER switch is released
B. Only if the START pushbutton is released
C. Only after the cool down period has elapsed
D. Immediately
132.The APU self test is performed from the MCDU. this function is available only:
A. If the APU is running
B. If the APU is not running
C. Doing the APU start sequence
D. If the START pushbutton is pressed in
136.What happen when the passenger door is opened from the outside and the slide
system is armed?
A. The locking mechanism is blocked
B. The escape slide will deploy
C. The slide system is disarmed
D. There is no possibility to open the door from the outside
137.What happen when the emergency exit door of A320 aircraft is opened from the
outside and the slide system is armed?
A. The locking mechanism is blocked
B. The escape slide will deploy
C. The slide system is disarmed
D. There is no possibility to open the door from the outside
139.How the operator is warned, when there is a residual pressure in the cabin?
A. By a white flushing light.
B. By a red flushing light.
C. By an ember flushing light.
140.What does the green light fitted near the manual selector valve of the cargo door
indicate?
A. The yellow hydraulic pressure is available to operate the door.
B. The door is fully opened and locked.
C. The door is correctly unlatched and unlocked
143.When does the residual cabin pressure red light come on?
A. When all the engines are not running, the parking brake is applied and the residual
cabin pressure exceeds 2.5 mbars
B. When the engines are not running, the slide is disarmed and the residual cabin
pressure exceeds 2.5 mbars
C. When the engines are not running, the parking brake is applied, the slide is disarmed
and the residual cabin pressure exceeds 2.5 mbars
145.The air stoppers are installed between the PAX door and the door frame
A. Prevent the cold air from penetrating into the cabin
B. Prevent the water comes into the cabin
C. Protect the door structure during operation.
147.The pressurization of the cargo door hydraulic system does not occur when:
A. The locking mechanism is in the locked condition.
B. The door not in fully close or/and open position.
C. The door not in fully open position.
D. The door is operated with hand pump
157.If the cabin emergency door is opened from outer side with the escape slide in
ARMED mode.
A. The ARMED mode of the escape slide changes to DISARMED mode as well as
passenger door.
B. The escape slide will deploy.
C. The door can not be opened.
158. Where the escape slide pack of cabin emergency door located?
A. Holds on the door.
B. Holds in a container underneath the door.
C. Holds on the overhead stowage compartment.
163.How many valves are used during the draining operation of water system?
A. One.
B. Two.
C. Three.
165.What happen when the emergency exit door of A321 aircraft is opened from the
outside and slide system is armed?
A. The locking mechanism is blocked
B. The escape slide will deploy
C. The slide system is disarmed
D. There is no possibility to open the door from the outside
166.Is it possible to fill the A321 aircraft water tank without electrical supplied?
A. Yes, fill/overflow drain valve can operate manually
B. Yes, but when finished you must manually return the control handle to the
NORMAL position to close the fill/overflow drain valve
C. No, because level transmitter can not send signal to close the fill/overflow drain
valve
D. No, because the fill/overflow drain valve operate electrically
167.The APU of A321 aircraft can normally be supplied with the fuel by:
A. Only the APU pump
B. Only the LH main pumps
C. LH main pumps or APU fuel pump
201.How can you assure that the oil servicing of starter is accomplished?
A. Checking the engine oil sign glass.
B. Check ECAM indication.
C. Check the oil flows though the overflow port.
204.“V2530-A5” means:
A. Engine is rated at max thrust of 25300 lbs to install in the Airbus A/C.
B. Engine is rated at max thrust of 30000 lbs to install in the Airbus A/C.
C. Engine is rated at max thrust of 25000 lbs to install in the Airbus A/C.
206.Reverser cowling:
A. Is attached to the engine core by 6 hinges each half.
B. Is hold closed by 5 single latches.
C. Should be opened/closed using the Auxiliary latch assembly.
208.Fan cowls:
A. Must be held open by both struts each when the wind is more than 26 knots (30
mph).
B. Should be opened by releasing 6 latches in sequence from the front to the rear.
C. Must always be held open by both struts each.
214.Which filters in the oil system have associated “filter clog” messages on the
ECAM?
A. Pressure Scavenge and Scavenge strainers.
B. Pressure only.
C. Scavenge only.
215.Which normal indications are displayed on the ECAM for the oil system?
A. Oil differential pressure, oil temperature, oil tank quantity.
B. Oil temperature, oil pressure.
C. Oil differential pressure, oil quantity,