Professional Documents
Culture Documents
3. Water elevation on a tank is 10 meter. If P=ρgh and ρ =1000kg /m3, g=9.81 m/sec. what is the pressure of
the water inside the tank:
a. 100 KPa -150 KPa -450 KPa -981 KPa
4. If you put a cup of water in a room, the moistures will accumulate on the side of the glass when;
1. The water temperature is less than the dew point of the room air.
2. The water temperature is less than the dew point of the room air.
3. The wet bulb temperature is less than the dry bulb temperature of the room air.
4. Both the wet bulb temp and the dry bulb are the same.
a. 1 & 3 -2 & 3 -1 & 4 -2 & 4
8. The duct installed at the side of the indoor unit of the AC unit is used for;
a. Remove the condensate water accumulated on the evaporator.
b. Remove the condensate water accumulated on the condenser.
c. Make more ventilation.
d. Cannot recall.
a. The input is a sound and the output is a signal. -The input is a signal and the output is a sound.
b. Both input and outputs are sounds. -Both input and outputs are signals.
12. What is the force that cause the body to float on the fluid surface.
13. What is the least level of WBS
14. Visual Inspection for the manual call point as Per NFPA 72
15. NFPA trained person takes minimum time for investigation and Evaluation and reset fire preventive system
17. As per NFPA 72, The Audible devices are frequently visually inspected:
18. A Biding Manager. On the closing date of the bid he received a call from one of the bidding firms asking him to
extend the bidding period by one day as they couldn’t finish the documents. Bob is to:
a. Accept extending the bidding period by one day. -Refuse his request.
b. Telling the Firm about the other firms prices. -Tell him that he will think about it and revert back.
20. An object that deforms continuously under applied shear stress is called:
a- Solid -b- Liquid -c- Gas -d- Fluid
22. Pipe with diameter 5mm and flow pass through it with speed 50m/s, the flow will be:
23. Force applied on the radius of circle, the direction of the centripetal force ……. From the center:
a- Toward. -Away.
27. Glass with cold water temperature, the condensation on the outer surface of the glass due to:
a- The wet temperature of the air is less than the due point.
b- The wet temperature of the air is higher than the due point.
c- The dry and wet temperature of the air is higher than the dry temperature of the glass.
d- The temperature ….
29. equipment with tags or labels that assuring the manufacturer has conducted the required test and apply the
standard
31. Chief cooker inside the kitchen left the fridge door open, and come after tow days then the room temperature
will be:
33. Refrigerant 134A chemical formula: It is CH2FCF3 but in test they write it as C2H2F4
7) Which one of the following is the most economical method of starting single phase
MOTOR?
a) Low Pass Filter - b) High Pas Filter c) Band Pass Filter d) None of the above.
a) Pipe Lining. -b) Voltage sensing -c) Parallelizing -d) None of the above
14) Major factor that has to be considered when designing a distribution system is,
a) Efficiency - b) Voltage Regulation - c) PF - d) Reliability
a) Power system with high short circuit capacity and high sensitivity to harmonics
b) Power system with high short circuit capacity and low sensitivity to harmonics
c) Power system with low short circuit capacity and high sensitivity to harmonics
c) Power system with low short circuit capacity and low sensitivity to harmonics
d) Diff Amplifier
18) Which of the following discipline is most suitable for doing a natural gas pipeline
work?
d) Civil Engg
c) Safety
a) Input Imp
b) O/P imp
c) System Voltage
24) When I current is passing through R resistance for a time period of t seconds, then
the electrical energy generated will be:-