Professional Documents
Culture Documents
2S BET LOURENÇO
Ø
MULTÍMETRO
0-‐32
VDC
Ø
CHAVE
PHILIPS
NÃO
MAGNÉTICA
Page 2-2
AFCS
TroubleshooUng
SecUon
2
AFCS
AnnunciaUons
SecUon
2
SET>ACTIVE Feature
Data can be manually copied from one column to the other by using the following two softkeys:
• SET>ACTV (read ‘Set to Active’) softkey: Allows the installer to send the information in the
SET column (data stored in the master configuration module) to the ACTV column (data used by
LRU).
• ACTV>SET (read ‘Active to Set’) softkey: Causes the LRUs current settings to be copied to the
master configuration module as SET items.
In the first example shown in Figure 1-11, the SET columns do not match the ACTIVE columns.
The inequality between SET and ACTIVE indicates a configuration mismatch. By pressing the
SET>ACTV softkey, this copies the SET column to the LRU unit’s configuration memory. The
settings then become the ACTIVE settings for the LRU being configured.
SET/ACTIVE Feature
Configuration Mismatch
Master Configuration Module LRU Memory Master Configuration Module LRU Memory
“SET” “ACTIVE” “SET” “ACTIVE”
Press the SET >ACTIVE Soft key to update the configuration for the LRU. In
this case we have selected the GIA1 from the GIA page group
SET>ACTIVE Feature
Configuration Correct
Master Configuration Module LRU Memory Master Configuration Module LRU Memory
“SET” “ACTIVE” “SET” “ACTIVE”
After pressing the SET>ACTIVE Soft Key, the two columns should match.
ACTIVE > SET Feature
WARNING
The ACTV>SET softkey must be used with caution! If an improperly configured unit is installed,
this softkey causes the wrong configuration to replace the correct aircraft configuration!
FIOS EXPOSTOS FORAS DOS
CONECTOR E PINOS CORRETOS
PINOS
2S BET LOURENÇO