Professional Documents
Culture Documents
Introduction.........................................................3-4
First Focal Plane Description.............................5
MD1 MRAD Subtensions...................................5
MD2 MOA Subtensions......................................5
Ranging Explanation...........................................6-7
Ranging Example.................................................8
Holdover Explanation........................................9
Holdover Example................................................10
MD1
3
MD2
4
First (Front) Focal Plane Riflescopes
First (or Front) Focal Plane riflescopes have the reticle installed
at the front of the erector tube, forward of the magnification
lens. When the magnification is increased, the reticle increases
in proportion to the image you are viewing. As a result, the
spacing between the actual reticle marks will always subtend
the same distance at any magnification setting. This allows
the shooter to quickly and accurately mil, hold over or hold off
regardless of the magnification setting.
5
MD1
Example:
Ranging an E-type silhouette target (40” tall x 19.5” wide)
19.5 x 27.8
= 452 Yards
1.2 mrad’s
8
Elevation Holdovers
After the distance has been calculated using the reticle or laser
rangefinder, the MD1 & MD2 reticles can be used for holdover
to compensate for bullet drop. Note that it may be necessary to
aim between hashmarks for the most accurate shot placement.
EOTech recommends shooters create and use a DOPE chart
(Data On Previous Engagements) to quickly identify their bullet
drop at a given range.
If the shooter prefers, the elevation dial can also be used to dial-
in your adjustment to compensate for bullet drop. When using
the dial for elevation adjustment, always use the center of the
crosshair.
9
Example: Elevation holdover
10
For prompt, professional and friendly service contact EOTech at
the following location.
EOTech Inc.
1201 E. Ellsworth Road - Ann Arbor, MI 48108
888.EOTHOLO (888.368.4656)
www.eotechinc.com
Contacting EOTech for repair:
1. Visit the manufacturer’s website at http://www.eotechinc.
com
2. Click on the customer service & support tab in the menu
bar and then click the Return Authorization Request Form.
3. Call or email L-3 EOTech’s customer service department
at the following: 888.EOTHOLO (888.368.4656), support.
eotech@l-3com.com
4. Be sure to leave a name, contact number, return shipping
address and failure description in the email or voice mail.
This will allow the manufacturer to generate a Return
Authorization Number (RA#) to include with the riflescope.
DO NOT SHIP THE SCOPE WITHOUT A RETURN
AUTHORIZATION NUMBER (this will severely delay the
turn-around time on repair or replacement).
5. Send the unit postage prepaid to the address below. Please
include your name, address, phone number, RA# and a
written description of the problem. Whenever possible,
ship the product in its original box.
L-3 Communications EOTech, Inc.
Warranty and Service Department
1201 E. Ellsworth Road
Ann Arbor, Michigan, 48108
U.S.A.
Reference RA#
11
VD1904 Rev A