Professional Documents
Culture Documents
23/2/2021 PRINT
372: Signal description Central Electronic Module
(CEM)
Signal
description
Central
Electronic
Module (CEM)
General
All values given
below are between
the terminals
stated in column 1
and terminal #D5
(power ground).
This applies unless
otherwise
indicated in the
last column.
Note! It is
important to
connect the
breakout box
and check the
ground
connections
before starting
to measure.
Signal table
Connector C1 (Green)
Signal type Ignition on Miscellaneous
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 2 of 11
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 3 of 11
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 4 of 11
Connector C2 (Brown)
Breakout Control Signal type Ignition off Ignition on Miscellaneous
box module Active / Not Active / Not
terminal terminal active active
#C1 #C2:1 Reserve
#C2 #C2:2 Reserve
#C3 #C2:3 Reserve
#C4 #C2:4 Reserve
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 5 of 11
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 6 of 11
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 7 of 11
(MMS), power
supply
#C58 #C2:58 BCM, accelerator Ulow Ubat
pedal, 15-feed
#C59 #C2:59 Stop (brake) lamps Ulow Ubat/Ulow
#C60 #C2:60 Reserve
#D1 #C2:61 Reserve
#D2 #C2:62 Right reversing Ulow Ubat/Ulow
lamp, power supply
#D3 #C2:63 Reserve
#D4 #C2:64 Power driver's seat Ubat/Ulow Ubat/Ulow
and power
passenger seat,
power supply
#D5 #C2:65 Power ground Ulow Ulow
#D6 #C2:66 Brake light switch, Ulow Ulow / Ubat
power supply
#D7 #C2:67 Tank hatch, Ubat/Ulow Ubat/Ulow
unlocking
#D8 #C2:68 Reserve
#D9 #C2:69 Occupant weight
sensor, power
supply
#D10 #C2:70 Power supply relay,
rear wiper motor
#D11 #C2:71 Trunk lid/tailgate, Ubat/Ulow Ubat/Ulow Does not apply
unlocking to the S80
#D12 #C2:72 Trunk lid/tailgate, Ubat/Ulow Ubat/Ulow Does not apply
locking to the S80
#D13 #C2:73 Left reversing Ulow Ubat/Ulow
lamp, power supply
#D14 #C2:74 Rear wiper motor,
control signal
#D15 #C2:75 Reserve
#D16 #C2:76 Fuel pump (FP), Ulow Ubat/Ulow
power supply
Connector C3 (Blue)
Breakout Control Signal type Ignition Ignition on Miscellaneous
box module off Active /
terminal terminal Active / Not active
Not active
#E1 #C3:1 Sun sensor, left, Ulow Ulow
ground
#E2 #C3:2 Sun sensor left Ulow U = 0.25 -
4.75 V
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 8 of 11
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 9 of 11
Hazard warning
flasher switch
illumination
#E42 #C3:42 Reserve
#E43 #C3:43 Reverse lockout,
power supply
#E44 #C3:44 Twilight sensor Ulow U = 0.25 -
4.75 V
#E45 #C3:45 Reserve
#E46 #C3:46 Reserve
#E47 #C3:47 Communication During communication
CAN_H high speed the voltage is 2.0 - 3.5 V
network
#E48 #C3:48 Communication CAN_L During communication
high speed network the voltage is 1.5 - 2.5 V
#E49 #C3:49 Communication LIN During communication Steering
bus 3 the voltage is 0 V - U bat column lock
module (SCL)
#E50 #C3:50 Communication LIN During communication Start control
bus 3 the voltage is 0 V - U bat module (SCU)
#E51 #C3:51 Communication LIN During communication Steering wheel
bus 1 the voltage is 0 V - U bat module (SWM)
#E52 #C3:52 Communication LIN During communication Light switch
bus 1 the voltage is 0 V - U bat module (LSM)
#E53 #C3:53 Reserve
#E54 #C3:54 Reserve
#E55 #C3:55 Forward sensing Ulow Ubat
module (FSM), power
supply
#E56 #C3:56 Reserve
#E57 #C3:57 Reserve
#E58 #C3:58 Reserve
#E59 #C3:59 Reserve
#E60 #C3:60 Reserve
#F1 #C3:61 Reserve
#F2 #C3:62 Reserve
#F3 #C3:63 Reserve
#F4 #C3:64 30-power supply, Ubat Ubat
infotainment control
module (ICM) and
integrated audio
module (IAM)
#F5 #C3:65 Reserve
#F6 #C3:66 15-power supply, Ulow Ubat
supplemental restraint
system module (SRS)
and OWS
#F7 #C3:67 Vanity mirror lighting, Ulow Ubat/Ulow Voltage supply
power supply alcolock
(option)
#F8 #C3:68 15-feed, PTC heater Ubat at ignition in position
and heated rear seat II; Ulow otherwise
switch
#F9 #C3:69 Driver information Ulow Ubat
module (DIM), power
supply
#F10 #C3:70 Ulow Ubat
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 10 of 11
Steering wheel
module (SWM), power
supply
#F11 #C3:71 Steering column lock Ulow Ubat/Ulow Does not apply
module (SCL), control to the
signal from driver USA/CDN
information module markets for
(DIM) 2009-
#F12 #C3:72
#F13 #C3:73 30-feed, data link Ubat Ubat
connector and climate
control module (CCM)
#F14 #C3:74 Start control unit, Ulow Ubat
(SCU), power supply
#F15 #C3:75 Sunroof, power supply Ubat Ubat
#F16 #C3:76 Relay, steering Does not apply
column lock module to the
(SCL), power supply USA/CDN
markets for
2009-
Connector C4 (Black)
Breakout Control Signal type Ignition off Ignition on Miscellaneous
box module Active / Active / Not
terminal terminal Not active active
#B21 #C4:1 Parking brake Ulow Ubat
switch illumination
and ashtray
lighting.
#B22 #C4:2 Seat belt reminder Ulow Ubat/Ulow
LED, power supply
#B23 #C4:3 Sunroof speed, Ulow Ubat-Ulow/Ulow
control signal
#B24 #C4:4 LIN bridge During communication the Vehicles with
voltage is 0 V - U bat keyless system
#B25 #C4:5 Communication During communication the
LIN bus 0 voltage is 0 V - U bat
#B26 #C4:6 High level brake Ulow Ubat/Ulow
light, power supply
#B27 #C4:7 Communication During communication the Movement
LIN bus 2 voltage is 0 V - U bat sensor (IMS)
#B28 #C4:8 Communication During communication the Rain sensor
LIN bus 2 voltage is 0 V - U bat module (RSM)
#B29 #C4:9 Reserve
#B30 #C4:10 Reserve
#B31 #C4:11 Reserve
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021
372: Signal description Central Electronic Module (CEM) Page 11 of 11
http://localhost/Vida/jsp/information/xml/xmlDocPrintPreview.jsp 23.02.2021