Professional Documents
Culture Documents
Chassis ID Path
03/Specifications/B12B, ARTIC/Standard
tightening torques
Model Identity
B12B 78359996
Publish date Operation No.
Tuesday, 21 February 2006
R3 - Group 030
Tightening torques
In cases where no specific tightening torque is stated, Volvo's standard tightening torque shall be
used for each of the following thread dimensions and screw classes.
M5 6±1
M6 10 ± 1,5
M7 17 ± 3
M8 24 ± 4
M10 48 ± 8
M12 85 ± 15
M14 140 ± 25
M16 220 ± 35
M18 290 ± 45
M20 430 ± 70
M22 580 ± 90
1/4
IMPACT 3.0 Thursday, 18 February 2010
M5 7,5 ± 1,2
M6 12 ± 2
M7 22 ± 3
M8 30 ± 5
M10 60 ± 10
M12 105 ± 20
M14 175 ± 30
M16 275 ± 45
M18 360 ± 55
M20 540 ± 90
1/4 10 ± 2,5
5/16 20 ± 5
3/8 40 ± 10
7/16 60 ± 15
1/2 100 ± 25
9/16 140 ± 30
5/8 200 ± 50
2/4
IMPACT 3.0 Thursday, 18 February 2010
The optimum speed for the tightening tool should be (300 ± 100) rpm
Recommended tightening torque (3 ± 0,25) Nm (torque dependant on clamp diameter)
The clamp must be tightened until the nut-head breaks off;
The clamps may not be re-used
14–17 2,0–2,5
20–32 2,5–3,5
38–50 3,5–4,5
56–75 5,0–6,0
85–112 5,0–6,0
138–165 5,0–6,0
3/4
IMPACT 3.0 Thursday, 18 February 2010
M10x1.0 18 ± 3 25 ± 4 10 ± 2 10 ± 2
M12x1.5 25 ± 4 40 ± 6 20 ± 3 20 ± 3
M14x1.5 25 ± 4 45 ± 7 25 ± 4 25 ± 4
M16x1.5 30 ± 5 50 ± 8 30 ± 5 30 ± 5
M22x1.5 30 ± 5 100 ± 15 60 ± 6 30 ± 5
1/4"-18 20 ± 3 20 ± 3
3/8"-18 30 ± 5 30 ± 5
Caution
To reduce the risk of damaging the seal, it is very important to ensure that the nipple does
not move while tightening the nut to the specified torque. The nipple must therefore be held
to stop it from moving. The nipple nut may not be torqued until after this sequence is
complete.
4/4