Professional Documents
Culture Documents
MECHATRONICS ENGINEERING
Preface
All praises are to GOD for all the blesses so that writer could finish this report after
conducting Internship` start from 17th July until 21st December 2020 in PT. Mega Technology
Batam. This report based on data and knowledge obtained by the writer during the Industrial
Work Practices. The writer realizes that in the preparation of this report there are a lot of
mistakes in both content and way of writing, that is why the writer expect criticism and
suggestion from a reader for the improvement of this report for the foreseeable future,
especially for junior who will carry out the Industrial Work Practice later and for other general
readers.
Abstract
Table of contents.
Introduction of PT Mega Technology Batam.
Mega Technology Batam
PVC Injection
Part of Injection Molding Machine
Operational Concept
Process
Conclusion
References
2|Page
MECHATRONICS ENGINEERING
Table of Contents
Preface
......................................................................................................................................... 2
Abstract
....................................................................................................................................... 2
Table Of Contents
........................................................................................................................ 3 Mega
Technology Batam ............................................................................................................. 4
PVC Injection
.............................................................................................................................. 4 Part of
Injection Molding Machine .............................................................................................. 4
Operational Concept
.................................................................................................................... 5 Process
........................................................................................................................................ 5
Conclusion
................................................................................................................................... 7
References
................................................................................................................................... 7
3|Page
MECHATRONICS ENGINEERING
Introduction
PVC Injection
An Injection molding machine, or (Injection molding machine BrE), also known as an
injection press, is a machine for manufacturing plastic products by the injection molding
process. It consists of two main parts, an injection unit and a clamping unit.
4|P
age
MECHATRONICS ENGINEERING
Operational Concept
Operational concept of machine are heating PVC liquid using heater and floated
through screw barrel and cylinder the injecting into mold.
Process
1. First, the operator inserts the PVC liquid into the engine tank. Before the engine is
modified, the operator must climb the stairs to reach the tank.
3. Operator prepared the mold to be used. The mold must be filled with a
hook first.
5|Page
MECHATRONICS ENGINEERING
4. After that, placed the mold near the engine nozzle. Wait for a minutes. Then, remove
the fish from the mold and put in the water.
Chilling
Fish
6|Page
MECHATRONICS ENGINEERING
Conclusion
injection press, is a machine for manufacturing plastic products by the injection molding
process. It consists of two main parts, an injection unit and a clamping unit.
References
https://www.jasonmolding.com/four-basic-parts-of-injection-mol
ding machine/
http://laporanjurusanlain.com
http://www.buruhtoday.com/2019/07/upah-terakhir-tak-di-beri-pt-mega
7|Page