Professional Documents
Culture Documents
INTRODUCTION:
Proteus Design Suite (designed by Labcenter Electronics Ltd.) is a software tool set, mainly used
for creating schematics, simulating Electronics & Embedded Circuits and designing PCB
Layouts.
IN THIS LAB we will design a circuit in proteus and simulate the results. We will compare the results with
our calculated results as well.
PROJECT:
In this lab we will prove the voltage division and check for the voltage division formula.
Voltage Division:
When two resistors R1 and R2 are connected in series, the source voltage Vs is divided between them
such that the voltage across R1 is equal to :
Circuit Diagram:
CALCULATIONS
IT CAN BE SEEN USING THE CIRCUIT DIAGRAM THAT THE EQUIVALENT RESISTANCE OF R2||R3 IS IN
SERIES WITH R1.IN THIS CASE
R1=10k ohm
R2=20k ohm
R3=10k ohm
R 2 × R 3 20∗10
Now Req = = = 6.67k ohms
R 2+ R 3 20+10
Now using voltage division,
Let Vs=10V
SIMULATION:
RESULTS:
VR1=5.99V
VR2=4.00V
CONCLUSION:
The simulation results in proteus successfully supported our calculated results.
The END