Professional Documents
Culture Documents
Rev. : 00 Date :
Checks for Control Room Column Design & Drawing
Reference 01 : Bureau of Indian Standards ( IS : 456_2000), & Other relavent IS Standards
Reference 02 : Suzlon Technical Specification No.: ENG:PEV:T-012 , CEA Te
Standards for Construction of Electrical Plants and Electric Lines Regulations, 2010.
Sl.No Parameters to be Checked OK NOT OK
A DESIGN UNITS
All Design units are as per Standard International (SI) Metric System
1
B DESIGN ASSUMPTIONS
C DESIGN PARAMETERS
D DESIGN LOADS
2 Dynamic loads are as Per Vendor Data for Heavy Rotating Equipment
F COLUMN DESIGN
It shall called a column if its effective length will be three
1 times the least lateral dimension.
The nominal cover for a longitudinal reinforcement bar in a column should not
3 be less than 40mm or the diameter of the bars.
The diameter of lateral ties should be greater among, (1⁄4)th of the diameter of
4 the largest longitudinal bars. 6 mm
The Pitch or spacing of the lateral ties should not be
greater than the following. Least lateral dimension of the column. 16 times the
5 diameter of the mallest longitudinal bars. 300 mm
The Index Sheet has been coordinated with the current list of
3 architectural drawings with respect to drawing number and title.
Verification team
Reviewed & Verfied by Approved & Accepted by
Remarks
Name
Date
Sign.
CEA Technical
Remarks, if any
Approved & Accepted by
Accepted by
Pravinkumar Patil