Professional Documents
Culture Documents
Duty 1
Pumping Temperature: 40 °C
CIP Temperature: 90 °C
Flow rate: 20.0 m³/h
Specific gravity: 0.90
Viscosity: 93 cP
Discharge: 6.0 bar
Suction: Assumed sufficient NPSHa
Results for Duty 1
NPSH Required: 3.0 m lc
Shaft Speed/Power abs: 265 rpm / 5.54 kW
Pump construction
Rotorcase material: Stainless Steel
Port size/Standard: Ø80 / Tri-Clamp
Port orientation: Horizontal
Seal type: Single R90 Mechanical Seal
Seal materials: Carbon Solid / Stainless Steel
Flush: None
Rotor form material: Trilobe / 130 °C / Stainless Steel
Rated pressure: 7 bar
Elastomer material: FPM
Front cover: Front Cover with Relief Valve
Internal finish: Standard Ra ≤ 0.8/32
Heating jackets: No jacket
Rotorcase saddles: No saddles
Shaft orientation: Bottom
Lubrication shafts: Oil / Stainless Steel
Gear housing colour: Alfa Laval Blue
Traceability: Not Traceable
Drive specification
Drive manufacturer: Nord
Driver type: Geared Motor for Frequency Inverter
Enclosure: TEFV / IP55
Driver power: 7.5 kW
Driver speed: 285 rpm at 50 Hz
Voltage: 400D/690Y
Special Compliance: No Requirements
Efficiency Level: IE3
Mounting: Stainless Steel Standard Baseplate
Transmission: Flexible coupling covered by Stainless Steel Coupling Guard
Options included: