You are on page 1of 1

On a power system network the load is increasing represents the value of impedance?

Answer: decrease
2. To improve the efficiency of thermal power plant ________________ is placed between boiler and turbine.
Answer: Super heater
3. The rating of CB is in terms of? Answer: Voltage
4. Which of the following is not base load power plant? A. Pump storage. B. Run water. C. Diesel. D. Nuclear.
5. The common emitter short circuit current gain 1
6. Which of the prime mover is least efficient? A. Gas turbine. B. Petrol engine. C. Diesel engine. D. Steam engine.
7. By increasing frequency the current in series resonance circuit before Answer: increase before resonant and after
resonance decreases
8. A steam power generation has an overall efficiency of 20 %. 0.6 Kg of coal is burnt per kWh of electrical energy
generated. Calculated the calorific value of fuel? Answer: 7166.67 kCal/kg
9. If a fault occurs on any feeder, the fault current is Answer: much lower than with Un-sectional bus bar.
10. Half wave rectifier ripple factor 1.21
11. In case of photo conductor for Germanium when forbidden energy gap is 0.72 eV, the critical wavelength for
intrinsic excitation will be Answer: 1.73 um
12. Electrical field intensity on equi-potential surface is Answer: Perpendicular to surface
13. 3.5 A and 0.031kohm heat dissipated 379.5 watt
14. What will be the thermal efficiency of a 240 V, 1000 W electric kettle if it brings 2 liters of water at 15° C to
boiling point 15 Minutes? A. 74.56 %.B. 78.96 %.C. 79.33 %.D. 80.25 %.
15. Mechanical energy is supplied to a DC generator at the rate of 4200 J / S. The generator delivers 32.2 Amp at 120
V. How much energy is cost per minute of operation? A. 20060 J.B. 20160 J.C. 23060 J.D. 25060 J.
16. Norton equivalent current is Answer: short circuit current through load
17. What is Collector current? A. Drift current B. Diffusion current C. Base current
18. The sequence components of the fault current are as follows: Ipositive = j1.5 pu, Inegative = − j0.5 pu, Izero = − j
pu Which fault is this? Answer: LLG
19. An overhead line conductor has an inductance per unit length of L Henry. If the entire medium around the
conductor is filled with a dielectric material of permittivity ( ε ), then the inductance will be Answer: L/ ε20. 650-
33kV clearance between track and lowest conductor Answer: 6.1m
20. The only place where slip ring induction motors used in thermal power plants is Answer: Coal handling plant
21. Which equipment does not supply reactive power in HVDC converter stations? Answer: Series Capacitors

You might also like