You are on page 1of 9

PARTS MANUAL

BELL B20D 18000L


LOW PROFILE TANKER

THIS PARTS MANUAL REFERS TO THE FOLLOWING TANK ONLY:


WT-0419-18

June 2012
INTRODUCTION
This manual has been produced to assist you in ordering of parts for the maintenance
of your Engineering Top Tech machine.

Every effort has been made to ensure that the information in this manual was correct
at the time of publication. Engineering Top Tech has a policy of continuous product
development, improvement and design. Engineering Top Tech reserves the right to
change, amend and update the design of its product at any time without prior notice.
With this policy, changes may have occurred that are not included in this manual.
Whilst every endeavour has been made to provide accurate and reliable information,
Engineering Top Tech. specifically disclaims any actual or implied warranty and
under no circumstances shall be liable for any loss, damage or injury to person or
property suffered, whether direct, or indirect or consequential, arising from the use of
this manual. In particular and without detracting from the above, the disclaimer also
applies in the event of any specification, warning, or representation contained in this
manual being inadequate, inaccurate, or unintentionally misleading.

The following address list was correct as at June 2012.

Engineering Top Tech Tel: (035) 7511630


6 Brass link, Fax: (035) 7511633
Alton Email: info@ett.co.za
Richards Bay Web: www.ett.co.za
3900
INDEX

 Tank rear

 Tank front

 Water level gauge

 Hydraulic motor and pump

 Hydraulic Schematics
Tank Rear

5
6

7
4

10 11
8 9

ITEM DESCRIPTION PART No. QTY


1 1” Nozzles 201-400-12 4
2 Spot/Reverse Light (LED type) 201-240-33 1
3 Number plate light 201-400-05 1
4 Valve control handle 201-400-10 1
5 Parrot Coupling on suction hose 201-400-16 1
6 3” Valves 201-400-09 2
7 Hydrant Valve 201-265-01 1
8 Indicator light (LED type) 201-240-18 2
9 Brake Light (LED type) 201-240-17 2
10 4” Butterfly Valve 201-400-08 1
11 3” Bellows 201-241-06 1
Tank Front

ITEM DESCRIPTION PART No. QTY


1 Tie Down Bolt M36x200 H/T 2
-Washer 100x38x12 M/S 4
-Nut M36 NYLOCK 2
-Rubber Washer 100x38x12 8
Water level Gauge

ITEM DESCRIPTION PART No. QTY


1 Level Gauge 201-240-22 1

You might also like