Professional Documents
Culture Documents
Measurements
Velleman Oscilloscope
When measuring the amplitude of a signal, make sure that one of the
cursors located right at ground, verifying this using the readout of one of
the cursor readings.
The phase angle of the signal on Channel 2 using the signal on Channel 1
as the reference is 46.8o using the technique described in Phase Delay.pdf.
Single Frequency Measurements
• Select Waveform Parameters under View on
the upper toolbar of the oscilloscope program.
The magnitudes of the signals on
Channel 1 and Channel 2 are
measured in several different ways -
make sure that you select the
correct parameter for the type of
measurement requested.