Professional Documents
Culture Documents
Total Marks 25
Student Score : 24
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 1/12
6/1/2021 vmedulife Learner Dashboard
1 ] Question : During subtraction function,When the result is _________,the coil is OFF . [Single Correct] [ 1 Mark/s]
1 ) Positive
2 ) Any number
3) Negative
4 ) None
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 2/12
6/1/2021 vmedulife Learner Dashboard
3 ] Question : The scan time is the time required: [Single Correct] [ 1 Mark/s]
1 ) To record the status of all output devices
2 ) To record the status of all input devices
3) To execute one cycle of program
4 ) for the information to pass fro input to output
4 ] Question : During the program scan,data in the ________ table is applied to the user program. [Single Correct] [ 1
Mark/s]
1) Input status
2 ) Program Status
3 ) Output status
4 ) PLC status
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 3/12
6/1/2021 vmedulife Learner Dashboard
6 ] Question : A__________ register holds the contents of a calculation,arithmetic or logic. [Single Correct] [ 1
Mark/s]
1 ) Output Register
2 ) Outpu Group Register
3 ) Input Group Register
4) Holding Register
7 ] Question : The part of the PLC where inputs and outputs are connected are [Single Correct] [ 1 Mark/s]
1 ) Processoor
2) Input/Output Intrerface
3 ) Memory
4 ) Power Supply
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 4/12
6/1/2021 vmedulife Learner Dashboard
8 ] Question : In the division function operand-1 register is ________ registers wide [Single Correct] [ 1 Mark/s]
1 ) One
2 ) Three
3) Two
4 ) One or Two
9 ] Question : During the addition function, the resultig value appeared in a ___________ [Single Correct] [ 1 Mark/s]
1) Destination Register
2 ) Operand-2
3 ) Operand-1
4 ) Operand-3
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 5/12
6/1/2021 vmedulife Learner Dashboard
10 ] Question : In the multiplication function destination register is __________registers wide. [Single Correct] [ 1
Mark/s]
1) Two
2 ) Three
3 ) One
4 ) Four
11 ] Question : Which is a false statement regarding DAQ (Data acquisition) systems? [Single Correct] [ 1 Mark/s]
1 ) Signal conditioning can be done
2) DAQ system can generate its own physical sample sets
3 ) It can measure physical phenomenon which can be sampled
4 ) Analog to digital conversion can be done
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 6/12
6/1/2021 vmedulife Learner Dashboard
13 ] Question : The processor module of PLC is where the: [Single Correct] [ 1 Mark/s]
1) Ladder Logic program is stored
2 ) Sensors are located
3 ) Input connections are made
4 ) Output Connections are made
14 ] Question : When _______ contact closes,the function carries out some kind of action. [Single Correct] [ 1
Mark/s]
1 ) Normally Closed
2 ) Latch System
3) Normally Open
4 ) Unlatch System
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 7/12
6/1/2021 vmedulife Learner Dashboard
15 ] Question : The main difference between a PLC and relay cotrol system is that: [Single Correct] [ 1 Mark/s]
1 ) Different types of input devices are used
2 ) Different input and output voltage levels are used
3 ) Different types of output devices are used
4) One uses hardwired relay control logic and the other uses programmed instructions
16 ] Question : The o/p of each rung is mentioned at the ---------------side of the ladder diagram [Single Correct] [ 1
Mark/s]
1) Right
2 ) Middle
3 ) Left
4 ) Top
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 8/12
6/1/2021 vmedulife Learner Dashboard
17 ] Question : Which of the following is not a function of a PLC programming Device? [Single Correct] [ 1 Mark/s]
1 ) To change the user program
2 ) To monitor the user program
3) To execute the user program
4 ) To enter the user program
18 ] Question : The key feature of the PCI BUS is [Single Correct] [ 1 Mark/s]
1) Plug and Play capability
2 ) Expansion of Bandwidth
3 ) Low cost connectivity
4 ) High Accuracy
19 ] Question : ____________ track the number of events that take place in a process [Single Correct] [ 1 Mark/s]
1 ) Off delay Timer
2) Up/down counter
3 ) On deay Timer
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 9/12
6/1/2021 vmedulife Learner Dashboard
4 ) Internal Memory
20 ] Question : What type of interface does a DAQ (Data acquisition) hardware creates? [Single Correct] [ 1 Mark/s]
1 ) Interface between two dissimilar signals
2) Interface between a computer and signal
3 ) Interface between two similar signals
4 ) Interface between two similar hardware
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 10/12
6/1/2021 vmedulife Learner Dashboard
22 ] Question : When _______ contact opens,the function carries out some kind of action. [Single Correct] [ 1
Mark/s]
1) Normally Closed
2 ) Latch System
3 ) Normally Open
4 ) Unlatch System
23 ] Question : The PCI follows a set of standards primarily used in _____ PCs. [Single Correct] [ 1 Mark/s]
1 ) Motorola
2) IBM
3 ) Intel
4 ) SUN
24 ] Question : Switches,contacts and other devices are inserted in the ladder line starting on_______. [Single
Correct] [ 1 Mark/s]
1 ) Right
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 11/12
6/1/2021 vmedulife Learner Dashboard
2 ) Middle
3) Left
4 ) Top
https://www.vmedulife.com/student/StudentPerformance.php?uid=MjQzMzc=&gid=MjczMA== 12/12