Professional Documents
Culture Documents
Pressure Sensors
EP71120
Pressure Sensors
Water ++ ++ ++ ++
Aromatic
++ - - ++
hydrocarbons
Halogenated
+ - - +
solvents
Acid ++ + - ++
Lye - ++ + ++
Vegetable oil
++ - ++ ++
Animal fat
Fuel
Lubricating oil ++ - + ++
Hydraulic oil
7-segment display
Display rotatable
Dimensions
G3/4
S1 S2
78
90
S1 S2 20
- -
32
+
12
M12 x 1
50 44
91
Analog output
7-segment display
Display rotatable
Design DC • G3/4
Dimensions
G3/4
78
90
A4 A20 20
- -
32
+
12
M12 x 1
50 44
91
NC/NO programmable
Display rotatable
Design DC • G3/4
Dimensions
G3/4
S1
S2
78
90
+- 20
41
OK
12
M12 x 1
50 44
91
2 (1) BN
L+
1: BN (2) WH
2: WH (4) BK
3 1 S1 S2
3: BU
(3) BU
4: BK L-
4 RL
Switching output
S1 / S2 PNP NO/NC programmable
Output voltage +UB – 1.5 V
Time delay < 8 ms
Rise time < 400 μs with RL < 400 or IL > 4.5 mA, respectively
Front view
Notice
Install signal and measurement wires separate from power- Keypad for
+-
programming
carrying wires. Use only shielded wires for signals and measu-
rement. Ground the shield only on one side. Operate inductive OK
loads like relays or auxiliary contactors (used to avoid voltage
spikes) only with a recovery diode or a RC module.
Program the sensor by means of the programming buttons:
Before installation, make sure that the sensor membrane's
gasket is suitable for the medium you will use. Our factory OK button: Enter the submenu and accept the selected
provides a fluoroelastomer (FPM) gasket. values.
The sensor is delivered with pre-programmed default settings.
You must first enter an access code if you wish to change the Arrow button: Jumps from one spot in the menu to another.
programmed parameters to meet your requirements. Please
Changes the +/- button's direction of action.
refer to the operating instructions manual for this code.
Changes the setting in a selection menu.
Analog output
Design DC • G3/4
Dimensions
G3/4
78
90
20
32
12
M12 x 1
50 44
91
L+ mA
(1) BN 20
2
1: BN 16
2: - (4) BK
3 1 12
3: BU 4...20mA
4: BK 8
RL
4 (3) BU 4
L- 0 5 10 15 20 25 30 mbar
https://ege-elektronik.com/en/organisation/ege/
EGE-Elektronik
Spezial-Sensoren GmbH
Ravensberg 34 • 24214 Gettorf • Germany
T +49 (0) 4346-41580 F +49 (0) 4346-5658
info@ege-elektronik.com
ege-elektronik.com
EP71120