Professional Documents
Culture Documents
Utilization of Electrical Energy MCQ PDF
Utilization of Electrical Energy MCQ PDF
IN
1) If the blowpipe is moved to and fro frequently while cutting the kerf will
1. not be affected
2. be less
3. of correct size
4. be more
Answer-D
Answer-D
3) The top edge is melted round and the cutface is not smooth in gas cutting. This is due to
Answer-C
4) In a gas cut plate, the cut shows groove sand has deep drag lines. This is due to
Answer-A
5) In a gas cut plate, the cut is high quality although there is some surface roughness caused by
vertical drag lines.This is due to
Answer-A
1|Page
WWW.ALLEXAMREVIEW.COM WWW.ALLEXAMREVIEW.IN
6) The size of the cutting nozzle used in oxyacetylene cutting process depends mainly on
Answer-A
1. T-joint
2. Corner joint
3. lap joint
4. butt joint
Answer-D
8) Double-V and double-U butt welds are used for plates of thickness
1. 1 - 5 mm
2. 5 - 10 mm
3. 10 - 15 mm
4. above 15 mm
Answer-D
1. Carbon
2. Tungsten
3. Graphite
4. Sodium
Answer-D
1. Gas welding
2. Arc welding
3. Thermit welding
4. Forge welding
Answer-D
2|Page
WWW.ALLEXAMREVIEW.COM WWW.ALLEXAMREVIEW.IN
1. Submerged
2. Plasma
3. Air-acetylene
4. Electro-slag
Answer-C
1. Arc welding
2. Resistance welding
3. Thermit welding with pressure
4. Forge welding
Answer-A
13) Which of the following welding process is used for welding of sheet metals in automobile and
air craft industries
1. Resistance welding
2. Thermit welding
3. Gas tungsten arc welding
4. Shield metal arc welding
Answer-A
1. Seam welding
2. Spot welding
3. Projection welding
4. Forge welding
Answer-D
Answer-B
3|Page
WWW.ALLEXAMREVIEW.COM WWW.ALLEXAMREVIEW.IN
1. Copper
2. Iron
3. Bronze
4. Aluminium
Answer-A
Answer-C
1. Oxidising flame
2. Carburising flame
3. Neutral flame
4. None of these
Answer-A
1. Oxidising flame
2. Carburising flame
3. Neutral flame
4. None of these
Answer-B
Answer-B
4|Page