You are on page 1of 1

Republic of the Philippines

Region VI- Western Visayas


Division of Capiz
Elizalde Academy, Inc.
5803 President Roxas, Capiz

1st UNIT EXAMINATION TEST IN SCIENCE 10


Name:____________________________________________Grade and Section:____________________Date:_____________
Direction: Read the questions carefully. Write your answer on the space provided for each number.
I. IDENTIFICATION:
____1. A mountain or hill, typically conical, having a crater or vent through which lava, rock fragments, hot vapor, and gas
are being or have been erupted from the earth’s crust.
____2. A theory which suggests that Earth’s crust is made of several plates that interact in several ways producing
earthquakes, volcanoes and other geologic features.
____3. Deep within the Earth, under tremendous pressure and at great temperatures, rock exists as a hot liquid called
______________.
____4. When the magma reaches the surface, it is called ___________.
____5. This zone goes through New Zealand, the Philippines, Japan, Alaska and along the western coasts of North and
South America.
____6. Vibration of Earth due to rapid release of energy.
____7. It is a break in ground along which movement has taken place
____8. It is a depression or deep canal in the seafloor produced by subduction process
____9. The force that squeezes rock together.
____10. The force that pulls rocks apart.
____11. The force that causes rocks on either side of a fault to slide past each other.
____12. The _______________which were formed by the convergence (compression) of Indo-Australian Plate and the
Eurasian Plate has many reverse and thrust faults.
____13. The _______________________ extends 960 km from Mexico to the north of California.
____14. Earthquakes which occur on the ocean floor produce giant sea waves called __________.
____15. Group of mountains produced through the convergence of two continental plates
____16. It is formed when two tectonic plates move apart from each other creating tension
____17. Formed by the divergence between oceanic plates while continental rift valley is formed between continental plates.
____18. It can also be found at the bottom of the ocean where seafloor spreading occurs.
____19. It is formed when two plates move toward each other.
____20. The oceanic plate bends downward into the mantle through the process called ________________.
____21. It is formed when two plates are sliding past each other.
____22. Transform fault boundary is also called ___________________.
____23. Divergent boundary is also known as _____________________________.
____24. A __________ is then formed creating an undersea canyon or linear fault valley.
____25. San Andreas Fault is an example ___________ boundary.
____26.
II. Write TRUE if the statement is correct and FALSE if the statement is incorrect.
____1. Tension causes rocks to be pulled apart and the rocks move down along the fault line.
____2. Compression causes rocks to squeeze together and rocks move up along a fault line.
____3. Shearing is the force that pulls rocks apart.
____4. Trench is a depression or deep canal in the seafloor produced by subduction process
____5. When the lava reaches the surface, it is called magma.
____6. Kilauea is the world’s most active volcano
____7. The San Andreas Fault extends 900 km from Mexico to the north of California.
____8. Scientists need to know the amount of stress applied as well as the elastic limit of the rock to determine when an
earthquake will occur.
____9. The Tsunami Warning Center is located in California.
____10. The amount of damage created by an earthquake depends on several factors.
III. ESSAY: (5 POINTS FOR EACH QUESTION)
1. What is the difference between volcanoes, mountain range, and earthquakes?
2. Define the three types of boundaries.
3. What is the importance’s of the three types of plate’s boundaries?
Prepared by:
MS. RODJHEN ANNE P. BARQUILLA

You might also like