Professional Documents
Culture Documents
Philippine Electronics Code Volume 2
Philippine Electronics Code Volume 2
349
Loading Next Page
GENERAL ENGINEERING & APPLIED SCIENCES
Requirements:
Location should be dry and located as close as possible to the
central point of the riser cable distribution facilities.
Location should be equipped with adequate lighting, and located 2.6
m (min.) above floor finish.
Location should be accessible to authorized company personnel
even during off hours and under lock and key or the terminations
under lockable cover.
Location should have enough working space e in front of all
terminations. Normally 900 mm and away from all hazards.
Location should be closely protected in areas where possible
physical damage may arise.
350
Loading Next Page
GENERAL ENGINEERING AND APPLIED SCIENCES
Provide with a 12 mm diameter non-metallic conduit to an approved
ground connections, to house the 14 mm2 (4.2 mm diameter)
ground wire.
Ceiling system – serves the same floor where the cables (wires) are
placed within the ceiling and brought down to desk locations.
351
Loading Next Page
GENERAL ENGINEERING & APPLIED SCIENCES
352
Loading Next Page
GENERAL ENGINEERING AND APPLIED SCIENCES
DEFINITION OF TERMS
353
Loading Next Page
GENERAL ENGINEERING & APPLIED SCIENCES
354
Loading Next Page
GENERAL ENGINEERING AND APPLIED SCIENCES
355
Loading Next Page
GENERAL ENGINEERING & APPLIED SCIENCES
356
Loading Next Page
GENERAL ENGINEERING AND APPLIED SCIENCES
Station – refers to the telephone instrument,
consisting of a transmitter, receiver and
associated apparatus which permit
telephone conversations with other
stations.
357
Loading Next Page
GENERAL ENGINEERING & APPLIED SCIENCES
A. drop wire
B. local loop
C. service entrance
D. subscribers loop
A. Aerial entrance
B. Underground entrance
C. Overhead entrance
D. Handhole
3. The size of the aerial entrance conduit shall not be less than ____ in
dimeter.
A. 20mm
B. 30mm
C. 40mm
D. 50mm
A. 20m
B. 30m
C. 40m
D. 50m
A. 2m
B. 3m
C. 4m
D. 1m
358
Loading Next Page
GENERAL ENGINEERING AND APPLIED SCIENCES
A. 4.4m
B. 3.3m
C. 5.5m
D. 6.6m
A. 3.5m
B. 5.5m
C. 4.5m
D. 6.1m
A. Aerial entrance
B. Underground entrance
C. Overhead entrance
D. Handhole
A. 800 mm
B. 600 mm
C. 900 mm
D. 700 mm
A. 300 mm
B. 100 mm
C. 50 mm
D. 150 mm
359
Loading Next Page
GENERAL ENGINEERING & APPLIED SCIENCES
A. 300 mm
B. 100 mm
C. 50 mm
D. 150 mm
12. The size of underground entrance conduit within the building shall be no
case smaller than ____in diameter when the service entrance does not
require use of a service box.
A. 50 mm
B. 75 mm
C. 65 mm
D. 45 mm
13. The use of handholes will be permitted for entrance cable not exceeding
____ pairs.
A. 20
B. 40
C. 30
D. 50
360
Loading Next Page
GENERAL ENGINEERING AND APPLIED SCIENCES
16. The use of service box will be permitted for entrance cable exceeding
____ pairs. The minimum size for service-box is
20. It is a point where cable from TELCO and the in-building distribution
system are terminated.
A. drop wire
B. terminal wire
C. main terminals
D. service box
21. The location of the main terminal must be equipped with adequate
lighting, and located at a minimum distance of ______above floor finish.
A. 1.3 m
B. 2.3 m
C. 1.6 m
D. 2.6 m
361
Loading Next Page
GENERAL ENGINEERING & APPLIED SCIENCES
22. The location of the main terminal should have enough working space in
front of all terminations. Normally _____away from all hazards.
A. 900 mm
B. 800 mm
C. 1000 mm
D. 700 mm
23. A main terminal required for terminating entrance cables using one or
more terminal blocks.
24. The backboard color for Main Telephone Terminal Cabinet (MTTC) used
other special services is:
A. white
B. yellow
C. black
D. blue
25. The backboard color for Main Telephone Terminal Cabinet (MTTC) used
as an entrance is:
A. white
B. yellow
C. black
D. blue
26. The backboard color for Main Telephone Terminal Cabinet (MTTC) used
for risers is:
A. white
B. yellow
C. black
D. blue
362
Loading Next Page
GENERAL ENGINEERING AND APPLIED SCIENCES
29. A riser system usually extends from the ground to the roof top of the
building with no floor separation similar to a ventilating shaft. Telephone
cable is not permitted in unless placed in metallic conduit.
A. Open Riser
B. Elevated Riser
C. Closed Riser
D. Underground Riser
A. Open Riser
B. Elevated Riser
C. Closed Riser
D. Underground Riser
31. Type of distribution system that provides concealment of the wires with
the least flexibility.
A. Conduit system
B. Under floor duct system
C. Ceiling system
D. Cellular floor system
363
Loading Next Page
GENERAL ENGINEERING & APPLIED SCIENCES
A. Conduit system
B. Under floor duct system
C. Ceiling system
D. Cellular floor system
33. Type of distribution system that serves the same floor where the cables
(wires) are placed within the ceiling and brought down to desk locations.
A. Conduit system
B. Under floor duct system
C. Ceiling system
D. Cellular floor system
A. Conduit system
B. Under floor duct system
C. Ceiling system
D. Cellular floor system
364
Loading Next Page
GENERAL ENGINEERING AND APPLIED SCIENCES
A. Shallow closet
B. walk in closet
C. Deep closet
D. raised closet
A. Shallow closet
B. walk in closet
C. Deep closet
D. raised closet
A. Cabinet
B. Apparatus Cabinet
C. Apparatus Closet
D. Closet
365
Loading Next Page
GENERAL ENGINEERING & APPLIED SCIENCES
41. Refers to the physical cable within a building that does not include
station wiring cable.
A. building cable
B. inside wire
C. inside drop
D. service drop
A. Conduit system
B. Under floor duct system
C. Ceiling system
D. Cellular floor raceways
43. A load-bearing floor unit containing one or more longitudinal cells which
may be closed on all sides or open at top or bottom.
A. box
B. closet
C. cabinet
D. cellular floor unit
44. The place where customer’s communication lines are terminated and
where the equipment which interconnects those lines is located.
A. trunk office
B. central office
C. toll station
D. tandem office
366
Loading Next Page