Professional Documents
Culture Documents
Relevant Commands
On the NodeB LMT, set or modify this parameter through SET MACEPARA (BTS3812E,
BTS3812A, BTS3812AE, BBU3806, BBU3806C), and query it through LST MACEPARA
(BTS3812E, BTS3812A, BTS3812AE, BBU3806, BBU3806C).
Parameter ID
RAD
Value Range
150 to 180000
Parameter Setting
The default value is 29000, which stands for 29 km.
You can set and adjust a value for this parameter based on the network planning and network
optimization result. In case the cell radius cannot be determined precisely, the set cell radius
must be greater than the required cell radius. The set cell radius, however, should be properly
great. Otherwise, the extra network resources are wasted and the system processing delay occurs.
Based on the data provided by relevant products, the handover synchronization time increases
by a maximum of 60 ms if the cell radius changes its value in increments of 3.75 km.
C T ON
When using the RRU, you must set the sum of the cell radius and the fiber transmission
delay as the cell radius.
If the access board of the NodeB is configured to support multiple sectors, the maximum
of the configurable cell radius is 30 km.
Relevant Commands
On the NodeB LMT, set the parameter through MOD LOCELL (BTS3812E, BTS3812A,
BTS3812AE, BBU3806, BBU3806C) and query it through LST LOCELL (BTS3812E,
BTS3812A, BTS3812AE, BBU3806, BBU3806C).
Parameter ID
HORAD
Value Range
0 to 180000
Parameter Setting
The default value is 0. The inner radius of a cell handover radius must be at least 78.125 m, that
is, 1 chip, shorter than the cell radius.
You can set and adjust a value for this parameter based on network planning and network
optimization result. In case the cell handover range cannot be determined precisely, the value
set for the cell handover radius must be smaller than the minimum cell handover radius required
for network planning. The set value, however, should be properly small. Otherwise, the system
processing delay may occur.
C T ON
When using the RRU, you must set the sum of the actual cell handover radius and the fiber
transmission delay as the cell handover radius.
Relevant Commands
On the NodeB LMT, set the parameter through MOD LOCELL (BTS3812E, BTS3812A,
BTS3812AE, BBU3806, BBU3806C) and query it through LST LOCELL (BTS3812E,
BTS3812A, BTS3812AE, BBU3806, BBU3806C).