Professional Documents
Culture Documents
Description
Technical Properties @ 250C:
Bituproof 12 is a dark brown emulsified bitumen liquid
Form: Thixotropic liquid
reinforced with rubber, formulated from selected raw
materials to form a high build elastomeric water proof Solid content: > 52%
and protec ve coa ng for concrete and masonry.
3 hr @ 25oC
Over coa ng me:
2 hr @ 35oC
Applications
Applica on
Bituproof 12 provides a water proofing and protec ve 5 to 45°C
temperature:
coa ng for:
Density: 1 ± 0.02 gm/ cm³
Retaining walls. Drying me:
Shaded or led roofs. 2 - 3 hr @ 25oC
(for thickness < 0.4
Under ground concrete founda ons. 1 - 2 hr @ 35oC
mm)
Wet floor areas such as bathrooms and kitchens.
Where minor live crakes may occur in concrete Service temperature: -20 to 60oC
substrates, Bituproof 12 will bridge such minor cracks. Resists to all water based
Basement walls. salts, mild alkaline and acid
Concrete slabs. Chemical resistance: solu ons, detergents and
most common aqueous
Advantages minerals
Elastomeric will bridge minor cracks which may occur Tensile strength:
0.2 MPa
in concrete substrates. ASTM D412, Die C
Resists a ack by chloride and sulphate ions present in
VOC: < 40 gr/ ltr.
ground water.
Single component.
Easily applied by brush, roller, broom or squeegee. Note: Drying me is affected by applied thickness,
Economical. temperature of substrate and wind condi ons
Solvent free, non flammable.
Asbestos free. Method of Use
Rot resistant.
Surface Preparation
Standards
Surface prepara on is very important to get the highest
Bituproof 12 complies with ASTM D1227 Type II, Class performance of Bituproof 12. Any surface to be coated
1. must be clean, sound and free of oil or grease. Any oil or
Bituproof 12 complies with ASTM C309 as a curing grease contamina on should be removed with a chemical
compound when applied with two coats at a rate degreaser.
of 4 m2/litre per coat.
All holes should be filled with a suitable cemen ous
mortar before applica on of Bituproof 12.
Primer Coat