Professional Documents
Culture Documents
Part 3 Technology and Livelihood Education
Part 3 Technology and Livelihood Education
com
D. material B.2.3 Hp
C. 2.5 Hp
13. A fluorescent lamp unit collected to a D. 23Hp
110v AC line takes 1.2A and requires
110w power. What is its power factor? 19. How many kilowatts does a certain
A. 0.9 Kw appliance consumes for 5 hrs. of use if it
B. 2 300 Kw has a power rating of 1.5Hp
C. 230 Kw A. 56. Kw
D. 2.3 Kw B. 7.5 Kw
C. 5.6 Kw
14. An electric heater uses 20kw-hr 8 D. 754 hp
hours. If the voltage across the heater is
240 volts. What is the heater resistance? 20. A cell supplies a load current 0.5A for
A. 2.5 ohms a period 20 hours until its terminal
B. 83.3 ohms voltage falls to an unacceptable level. How
C. 23.04 ohms long can it be expected to supply a
D. 2.30 ohms current of 100mA?
A. 50 hours
15. The resistance of a 230v incandescent B. 100 hours
lamp is 300 ohms. What current is C. 60 hours
required to operate the lamp? D. 70 hours
A. 0.85 A
B. 0.77 A 21. A battery is rated 200 Ah. If it used to
C. 1.30 A supply a constant current of 8A, how long
D. 7.74 A can the battery last until I become
unusable?
16. A group of lamps operates a current of A. 20 hours
12 A and a voltage of 120v. What is the B. 25 hours
total power of the lamps? C. 15 hours
A. 1.44kw D. 2.5 hours
B. 1.20kw
C. 1.34 kw 22. The resistance of 500 meters of a
D. 14.4kw certain wire is 125 ohms. What length of
the same wire will have a resistance of
17. What is the maximum load capacity of 60ohms?
15 A circuit breaker protecting a branch
circuits that supplies a continuous load? A. 24 meters
A. 15 A B. 255 meters
B. 10 A C. 240 meters
C. 12 A D. 235 metes
D. 14 A
23. If three equal resistance are
18. What is the horsepower rating of an connected in parallel, the equivalent
electric water pump if it has a power resisitance of the circuit will be ____ the
rating of 1.75 kw? value one resistor.
A. 2 hp A. three times
Get more Free LET Reviewers @ www.teachpinas.com
A. shall be
45. A short circuit can be detected by B. should be
using_________ . C. shall not be
A. an ohmmeter D. should not be
B. a meggar
C. an oscillscope 51. Light fixtures suspended from the
D. an ammeter ceiling by chains should wire so that the
wires ______________ .
46. The electrical plants for residential A. will be grounded
house include the following items EXCEPT B. will not touch the chains
one. Which one is this? C. will support the fixture
A. substation plan D. will not support fixture
B. location plan
C. floor plan showing location service 52. In rigid metal conduit wiring conduit
D. Layout of wiring plan for general of 15-20 mm diameter shall be supported
lightning and receptacles outlets at least every _________.
A. 2 500mm
47. If installed in raceway, conductors of B. 3 500mm
size _____ and larger shall be stranded. C. 1 800mm
A. 5.5mm D. 3 000mm
B. 8.0mm
C. 14mm 53. Why do conductors need additional
D. 3.5mm wiring insulators?
A. electrical wiring needs to be protected
48. At least _______of free conductor shall from mechanical harm
be left each outlet, junction and switch for B. wires are connected by joints therefore
splices or connection of fixtures o devices. needs reinsulations
A. 250mm C. wire touches wood surface therefore
B. 175mm need protection
C. 150mm D. wires skin is weak
D. 300mm
54. What is the total number of
49. A certain residential house has mechanical degrees that electrical pipe
lightning load of 1.1 kVA and a appliance run maybe bent between pull points?
load of 10a at 220v single phase, two A. 360 degrees
wires 60hz. The branch circuit fuse B. 180 degrees
protection for lightning and appliances C. 120 degrees
loads are ______ and_______, respective ly D. 270 degrees
A. 20A and 60A
B. 20 and 30 55. Rigid non-metallic conduit shall be
C. 15A and 30A supported within ______ of each box
D. 15A and 20A cabinet or other termination.
A. 600mm
50. Live vegetation or trees _________ used B. 800mm
for support of overhead conductors C. 900mm
spans. D. 760mm
Get more Free LET Reviewers @ www.teachpinas.com
C. amber
56. Electrical metallic tubing smaller than D. friction
___ electrical trade size shall NOT be used.
A. 12mm 62. The peak to peak voltage in a 117 Vac
B. 10mm outlet is _______.
C. 15mm A. 620 V
D. 20mm B. 165.5V
C. 331V
57. Type AC cable shall be secured by D. 220V
approved staples, straps, hanger or
similar fitting at intervals NOT exceeding 63. Which is a type of modulation where
________ . the amplitude of the carriers is change in
A. 1 250mm accordance with demodulating signal?
B. 1 300mm A. FM
C. 1 500mm B. PDM
D. 1 000mm C. A,
D. PCM
58. In concealed knob and tubewiring the
clearance to be maintainde between 64. The actual flow of current is form
conductors is _______ . ______ .
A. 65mm A. negative to positive
B . 45mm B. positive to negative
C. 76mm C. positive to positive
D. 50mm D. negative to negative
59. Three bulbs are connected in parallel 65. The rate of doing work is called
and controlled by a single switch. If one of ________ .
the three 3 bulbs is busted, what will A. energy
happen to the remaining bulbs. B. power
A. Will not lit C. voltage
B. Its brightness is reduced D. resistance
C. its brightness increases
D. its birghtness is maintiained. 66. MilliHenry is equal to _______.
A. 10th Henry
60. Which is a synchronous alternating- B. 100th Hnery
current machine that changes mechanical C. 1000th Henry
power into electrical power? D. 1000000th Henry
A. dynamo
B. Motor 67. An inductor opposes any changes in
C. Alternator ______________ .
D. Lathe machine A. voltage
61. The word electron was derived from B. current
the Greek word electron which means C. frequency
________. D. modulation
A. to rub
B. to rub
Get more Free LET Reviewers @ www.teachpinas.com
C. the same 87. When two capacitors the rise and fall
D. cannot be determined of alternating current and voltage?
A. Graph
81. Which is TRUE of a series DC motor B. Sine wave
with no load? C. Fluctuation
A. Tendo stop or not start D. Cycle
B. Maybe damaged by excessive speed
C. Has reverse direction 88. When two capacitors are connected in
D. becomes an AC generator parallel the capacitance will ______ .
A. increase
82. A fuse marked 250V, 650m can be B. since wave
used in circuits with an “open-fuse” C. decrease
supply voltage _________ . D. increase and decrease
A. 125 volts
B. 500 volts 89. Which circuit ha the most gain?
C. 5000 volts A. common emitter
D. 250 volts B. common collector
C. common base
83. To prevent transistor from getting hot, D. emitter follower
use _________ .
A. silicon grease 90. Which rectifier circuit uses four
B. insulator diodes for its rectification?
C. heat sink A. Half-wave rectifier
D. exhaust fan B. full-wave Center Tap
C. Full-wave Bridge rectifier
84. To obtain a higher value of resistance, D. Split type
resistors are _______ .
A. reverse 91. When a resistor is open, the resistance
B. parallel ______.
C. forward A. increase
D. series B. gets zero
C. decrease
85. Which fuse has its internal fusible D. is infinite
wire wrapped around an insulator?
A. a slow-blow type fuse 92. A low voltage power supply converts
B. An inductive fuse __________ .
C. a capacitive A. Ac voltage output
D. intended for high voltage fuse B. Pulsating DC voltage
C. DC output voltage
86. Which would be considered “basic D. AC and DC voltage outputs
components of a power supply?
A. Zener, regulator, transformer 93. When checking an open resistor using
B. Regulate, diode, AC power, load an ohmmeter the resistance reads _______ .
C. Transformer, bridge, capacitor, load A. zero level
D. Filter, regulator, rectifier, transformer B. high resistance but within the tolerance
C. infinite
Get more Free LET Reviewers @ www.teachpinas.com