Professional Documents
Culture Documents
12-00-00
SERVICING
GENERAL
This chapter contains the data required to service the helicopter.
Table 1 contains a list of applicable helicopters with their associated serial numbers and Flight Manual
document.
Module 12-11-01, Table 1, through Module 12-31-01, Table 1, contain the list of the recommended
intervals for fuel, oil, filter servicing, grease lubrication, and miscellaneous servicing.
For data on the consumable materials, refer to Standard Practices Manual (BHT-ALL-SPM).
CAUTION
For specific information on fuels, oils and fluids, refer as required to the applicable Flight Manual as
follows:
NOTE
Boost pumps and lower fuel quantity probe covers were introduced as
basic equipment at S/N 8693.
Figure 1 shows the location of all the access panels, drains and vents required for servicing the
helicopter. For the location of other panels required for maintenance access, refer to Chapter 53. For
the location of sight and level gauges, refer to specific system Module 12-12-00, figure 1, or Module 12
-13-01, figure 1, as required.
1. APU receptacle
2. Battery compartment door
3. FWD deck inspection door
4. Transmission area inspection door
5. Maintenance step door
6. Engine inlet plenum inspection window
7. LH Engine cowl door
8. Engine oil tank drain valve access door
9. AFT cowling
10. T/R driveshaft cover
11. T/R gearbox oil filler cap access door
12. Hydraulic filter access door (Bypass indicator)
13. Transmission inspection door RH (Oil level sight gauge)
14. Fuel shut-off valve access panel
15. Engine oil tank filler access door
16. Tailboom attachments access
17. AFT boost pump access cover
18. FWD boost pump access cover
19. Lower fuel probe access cover
Figure 1. Access Panels, Drains and Vents (Sheet 1 of 2)