Professional Documents
Culture Documents
1 Software Installation
This document is intended to guide the reader through the process of installing
AutoLaser for Microsoft Windows operating system. Now we also provides plug-in for
CAD, CorelDRAW, illustrator drawing software.
Note: When installing the plug-in, it needs to install the AutoLaser software at
the same time. So the plug-in is able to call the AutoLaser program to import
the drawing.
1) Open the AutoLaser installing program. Select the “Product” and “CorelLaser”
check box.
2) Click “Next” and click “Installation”. The Program copies the required files to the
computer. Windows should then display a message indicating that the
installation was successful. Click “Finish” to close.
Check whether the installation is successful.
2) The appearance of the small icon as shown in the following figure means
the successful installation and starting.
3) When finish drawing in CorelDRAW, click the icon button in the plug-in to import
this drawing to our AutoLaser.
First please make sure you have installed CAD 2004 to CAD 2013 of the full
version software.
1) Start CAD. Then select the menu items: [AutoCAD Classic]. If it was unable to
change to classic mode, the plug-in for importing drawing to AutoLaser would not
be displayed.
2) Open the AutoLaser installing program. Select the “Product” and “CADLaser”
check box. The installation steps are the same as the CorelDRAW plug-in.
3) Open the CAD software after the installation is complete. Then the
“CADLaser(C)” item was shown in the menu as shown below.
4) When finish drawing in CAD, click the “CADLaser” button to import this drawing
to our AutoLaser.
First please make sure you have installed AICS2 to AICC of the full version
software.
1) Open the AutoLaser installing program. Select the “Product” and “AILaser”
check box. The installation steps are the same as the CorelDRAW plug-in.
2) Open the AI software after the installation is complete. The “Laser Design” item
would be shown in the “Window” menu as shown below. Click “Export” to import
the drawing to our AutoLaser.
2 Troubleshooting
1) Open the “Uninstall or change a program” page (located in Control Panel/ All
Control Panel items/ Programs and Features) to check if the .net framework 3.5
is installed as shown below. If it was not installed. Please install it first and try to
open the AutoLaser again.
2) Install antivirus software. And check the AutoLaser installation package and
operating system was not infected by the virus.
3) Select the “System Library” to install the required system files for the AutoLaser
as shown below. And retry it.
2.2 The plug-in program runs failure
When a message box is shown below after click the import button, check the items in
section 2.1 to make sure the AutoLaser is able to run successfully.