Professional Documents
Culture Documents
Performance
Electric Motor
The Jetstream Model 4215 waterblast pump is capable of power input of 200 to 325 horsepower (242
kW). It is the most advanced and efficient compact waterblast pump in the industry. Combining the strength
and durability of a proven power end workhorse with the unparalleled simplicity, serviceability and versatility
of the UNx™ fluid end design, Jetstream bareshaft pumps are the best choice for those building their own
system or replacing a complicated, worn or unreliable pump.
Plunger Size : 11
Plunger Diameter : 1.100 in (27.94 mm)
No. of Plungers : 3
Plunger Stroke : 4.25” (108 mm)
Discharge Ports : 3/4” NPT Female
Top Ports (Accessory) : 1/2” NPT Female
MODEL 4215HF – PLUNGER #11
UNXTM FLUID END
PART BREAKDOWN
* Power end component included in drawing for convinience. Not included with new fluid ends.
** Optional Ceramic Plunger Available.
RUPTURE DISC HOLDERS
For protection from dangerous over-pressurization, rupture
discs function in a waterblast system analagous to the function
of fuses in an electrical circuit. When the system pressure
exceeds that of the burst disc, the disc bursts and allows water
to flow out of the holder's cap, relieving the system of high
pressure.
• May be used as primary and/or secondary relief devices
• Tamper-resistant design
• Discs are quickly and easily replaceable
• Assembly components machined from high
quality stainless steel
PART
ITEM DESCRIPTION
NO.
1 51033 Base
2 55316 18,000 psi Burst Disc
51052 20,000 psi Burst Disc
3 51040 Hold-Down Ring
4 51037 Cap
The quality of water that is supplied to your Jetstream pump can have a direct impact on performance.
Items like dissolved solids and pH values out of the allowable range can, either by themselves, or working in
concert with other properties of the water, lead to premature failure (such as cracking) of pump components
and related accessories.
Suspended gasses (tiny bubbles) in the water can also lead to premature component failure. These
gases can sometimes be detected visually by inspecting the water in the inlet tank for tiny bubbles or a milky
appearance.
As part of the installation and or operating procedures of this pump, an expert that specializes in water
quality should perform a water quality test. If your water is found to exceed any of the allowable
measurements in the chart below, you may want to consult with a company that specializes in water
purification and conditioning.
Recommended water quality levels for Jetstream UHP pumps
Note: Boiler water additives with either ammonia or amines are not allowed.
Note: If water that has been treated by either reverse osmosis or deionization is to be used in your pump, it is
important that it does not have a total dissolved solids (TDS) reading of less than 0.5 parts per million (PPM).
Water with a TDS reading of 0.5 PPM or less has been known to attack carbide components such as plungers
and back-up rings.
Filter System
Filter Housing
Filter Bags
Skid
Water Tank