This document provides preventative maintenance instructions for the PODS Calibration and Verification machine. It lists the machine's mechanical and pneumatic components that should be inspected and serviced periodically, including lubricating slide bearings every 6 months, checking slide rods for wear every 12 months, and draining and changing filters for the pneumatic system every 2 weeks and 12 months respectively. It also notes that test harnesses should be visually inspected for damage and cleaned regularly.
Original Description:
ejemplo de orden de mantenimiento preventivo de una maquina
This document provides preventative maintenance instructions for the PODS Calibration and Verification machine. It lists the machine's mechanical and pneumatic components that should be inspected and serviced periodically, including lubricating slide bearings every 6 months, checking slide rods for wear every 12 months, and draining and changing filters for the pneumatic system every 2 weeks and 12 months respectively. It also notes that test harnesses should be visually inspected for damage and cleaned regularly.
This document provides preventative maintenance instructions for the PODS Calibration and Verification machine. It lists the machine's mechanical and pneumatic components that should be inspected and serviced periodically, including lubricating slide bearings every 6 months, checking slide rods for wear every 12 months, and draining and changing filters for the pneumatic system every 2 weeks and 12 months respectively. It also notes that test harnesses should be visually inspected for damage and cleaned regularly.
To insure the proper operation of the PODS Calibration and Verification machine, the following preventative maintenance actions should be followed.
Component Description Action Frequency
Mechanical Svstem Horizontal slide bearings Lubricate with grease 6 months/1000 hours Horizontal slide rods Check for abnormal wear-replace 12 months/2000 hours Vertical slide rods Check for abnormal wear-replace 12 months/2000 hours Vertical slide bearings Check for abnormal wear-replace 12 months/2000 hours Cylinder clevis cotter pins Check for damage/missing 12 replace months/2000 hours Cylinder rod nuts Check for tightness - tighten 12 months/2000 hours Pneumatic System Filter/regulator Drain bowl 2 weeks / 100 hours Filter/regulator Change filter 12 months/2000 hours Air Conditioner Clean or Change filter 30 days
Test Harnesses Visually inspect test harness for bent or broken pins. Clean contact pins with approved electrical contact cleaner as needed. Inspect cable jacket for wear.
Refer to the individual component literature for maintenance on other system