Professional Documents
Culture Documents
Maintenance and Inspection Items
Maintenance and Inspection Items
1. 月维保项目及易损件更换
(先到为准)
Lubrication oil for HP water pump: the first time to replace oil is one month
when machine installation. After that to replace the oil in half year or after
高压旋转接头(9-10 个月)
滑环或密封圈: 1 年半-2 年
A/日检:Daily Inspection
自吸泵日检查
配比箱进液管出液管检测是否漏液
Inlet and outlet pipe in proportion box: to check if there is any leakage
喷嘴查看 是否有堵塞
调压阀气表每日查看一下 是否漏气
B/周检:Weekly Inspection
光电对射每周擦洗(白醋即可)
Ultrasonic Sensor to clean by week ( use soft pads with white vinegar)
来水)井水 1 年换(根据水质)
the filter installed forward inlet water pipe to clean 1 to 3 month( based on the
water quality); and suggest to change it 3 to 5 years.
新机框架螺丝:第一个月紧固,之后半年紧固
Screws of new machine: in first month, to Fasten all screws of beams. after that
悬臂固定螺丝:第一个月紧固,之后半年紧固
Fixing screw of swing arm: in first month, to Fasten all screws . after that by half
高压管接口螺丝:第一个月紧固,之后半年紧固
High pressure pipe interface screw: in first month, to Fasten all screws,after that
by half month
分钟。
wash machine stop using, it must flush all electronic proportioning pumps, at
least 30 minutes.
高压水泵地基固定螺丝,首月检查,之后半年检查
电机地基固定螺栓,首月检查紧固,之后半年检查
Basement screw of motor: in first month, to Fasten all screws,after that by half
month.
电气件:空开,接触器接线端螺丝紧固,首月检查禁锢,之后半年检查
天车行走塑料轮(轨道内)2 年更换一次。如有异响更换塑料轮内轴承。10
元左右
there is any abnormal sound, it need to change the bearing inside of plastic
wheel.
3-半年内对轨道梁内保养润滑抹油(黄油脂)
同步带传动齿轮保养润滑 3 个月到半年
白色同步带半年到 1 年检查是否松动
气泵罐定期放水(根据环境)半月-1 个月
Pump tank need to draw off water in regularly: half month to one month
配比箱内,泡沫水路电磁阀 1 个月清洗一次(黑色)
month.
喷嘴建议 5 年更换一批
High pressure water nozzles: suggest to change by 5 years.