Professional Documents
Culture Documents
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
CE
EMC DIRECTIVE (2014/30/EU)
TEST REPORT
Prepared for
EUGENE ADAMS
MATT HARRISON
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 2 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
TABLE OF CONTENTS
Section / Title PAGE
GENERAL REPORT SUMMARY 5
SUMMARY OF TEST RESULTS 6
SUMMARY OF TEST RESULTS continued 7
1. PURPOSE 8
2. ADMINISTRATIVE DATA 9
2.1 Location of Testing 9
2.2 Traceability Statement 9
2.3 Cognizant Personnel 9
2.4 Date Test Sample was received 9
2.5 Disposition of the Test Sample 9
2.6 Abbreviations and Acronyms 9
3. APPLICABLE DOCUMENTS 10
4. DESCRIPTION OF TEST CONFIGURATION 12
4.1 Description of Test Configuration – (Emissions) 12
4.2 Description of the Test Configuration – (Immunity) 14
5. LISTS OF EUT, ACCESSORIES AND TEST EQUIPMENT 16
5.1 EUT and Accessory List 16
5.2 Emissions Test Equipment 17
5.3 Immunity Test Equipment 18
5.4 Test Software 20
6. TEST SITE DESCRIPTION 21
6.1 Test Facility Description 21
6.2 EUT Mounting, Bonding and Grounding 21
6.3 Facility Environmental Characteristics 21
6.4 Measurement Uncertainty 21
7. TEST PROCEDURES 22
7.1 RF Emissions 22
7.2 Electrostatic Discharge Tests 27
7.3 Radio-Frequency Electromagnetic Field 30
7.4 Fast Transient Common Mode Tests 31
7.5 Surge Immunity Test 32
7.6 Conducted disturbances induced by RF Electromagnetic Field Test 33
7.7 Power Frequency Magnetic Field Test 34
7.8 Voltage Dips, Short Interruptions, and Voltage Variations 35
7.9 Quasi-Stationary Harmonics and Flicker Test 36
8. TEST PROCEDURE DEVIATIONS 37
9. CONCLUSIONS 37
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 3 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
LIST OF APPENDICES
APPENDIX TITLE
A Laboratory Accreditations
B Modifications to the EUT
C Additional Models Covered Under This Report
D Diagrams, Charts and Photos
Test Setup Diagrams
Antenna and Amplifier Gain Factors
Radiated and Conducted Emissions Photos
Immunity Photos
E Data Sheets
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 4 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
LIST OF FIGURES
FIGURE TITLE
LIST OF TABLES
TABLE TITLE
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 5 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
The measurement data and conclusions appearing herein relate only to the sample tested and this report may not be
reproduced in any form except in full, without the written permission of Compatible Electronics.
This report must not be used to claim product certification, approval or endorsement by NVLAP, NIST, or any agency
of the federal government.
The specification EN55024 is a product family EMC standard which references the following
specifications:
EN 61000-4-2
EN 61000-4-3
EN 61000-4-4
EN 61000-4-5
EN 61000-4-6
EN 61000-4-8
EN 61000-4-11
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 6 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
2 Conducted RF Emissions – Telecom Lines The EUT has no telecom lines; therefore this test was not performed.
150 kHz – 30 MHz.
3 Radiated RF Emissions, 30 MHz – 30000 MHz. Complies with the Class B limits of FCC, ICES-003, VCCI,
CNS13438, AS/NZS CISPR 32, and EN550324
See section 6.4 for Measurement Uncertainty
4 Direct ESD, Air Discharge, Complies with the relevant requirements of EN55024. The unit
2 kV, 4 kV, 8 kV, 12kV, and 15kV operates within the specifications. *See XX below for uncertainty
(insulated surfaces). notes.
5 Complies with the relevant requirements of EN55024. The unit
Direct ESD, Contact Discharge,
operates within the specifications. *See XX below for uncertainty
2 kV, 4 kV, and 8kV (conductive surfaces).
notes.
6 Indirect ESD, Complies with the relevant requirements of EN55024. The unit
2 kV, 4 kV, and 8kV (HCP & VCP). operates within the specifications. *See XX below for uncertainty
notes.
7 Complies with the requirements of EN55024. The unit operates within
Radio-Frequency Electromagnetic Field,
its specifications. *See XX below for uncertainty notes. Variations of
80 MHz to 2000 MHz, 10 V/m with an
measured field strength due to reflections from the EUT are not
amplitude modulated 1 kHz sine wave at 80%.
included in the uncertainty calculations.
8 Fast Transients Common Mode, 0.5 kV & 1.0 Complies with the requirements of EN55024. The unit operates within
kV on AC Power lines and 0.5 kV on data its specifications. *See XX below for uncertainty notes.
lines.
9 Surge Immunity Test Differential Mode, 0.5 Complies with the requirements of EN55024. The unit operates within
kV and 1.0 kV and common mode 2.0 kV on its specifications. *See XX below for uncertainty notes.
power lines.
10 Surge Immunity Test Telecommunication Lines The EUT has no telecommunication cables that connect directly to
0.5 kV and 1.0 kV outdoor cables; therefore this test was deemed unnecessary. *See XX
below for uncertainty notes.
11 Radio-Frequency Electromagnetic Conducted Complies with the requirements of EN55024. The unit operates within
Field, .150 MHz to 80 MHz, 3Vrms with an its specifications. *See XX below for uncertainty notes.
amplitude modulated 1 kHz sine wave at 80%.
12 Power Frequency Magnetic Field Susceptibility, Complies with the requirements of EN55024. The unit operates within
3 A/m @ 50Hz and 60Hz, X, Y, & Z-axis. its specifications. *See XX below for uncertainty notes.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 7 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 8 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
1. PURPOSE
This document is a Qualification test report based on the Emissions and Immunity tests performed on
the INTERNAL HARD DISK DRIVE, R/N: 800055. The emissions measurements were performed
according to the measurement procedure described in AS/NZS CISPR 32, ICES -003, VCCI,
CNS13438, and EN55032. The tests were performed in order to determine whether the
electromagnetic emissions from the equipment under test, referred to as EUT hereafter, are within the
Class B specification limits defined in CISPR 22 (EN55022) and EN55032 (Electromagnetic
compatibility of multimedia equipment – Emissions requirements).. Under paragraph G of section
15.109 of the Code of Federal Regulations Title 47, Part 15 of the FCC rules, FCC accepts the
international standards set forth in CISPR 22.
The immunity tests were performed according to the measurement procedure described in EN55024 -
(Information Technology Equipment – Immunity Characteristics – Limits and Methods of
Measurement). These tests were performed in order to determine whether the EUT would accept any
interference and still perform within the performance criteria described in section 4.2.1 of this report.
The tests were performed by Compatible Electronics personnel; also the unit was operated and
monitored for susceptibility by Compatible Electronics personnel.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 9 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
2. ADMINISTRATIVE DATA
2.1 Location of Testing
The emissions and immunity tests described herein were performed at the test facility of Compatible
Electronics, 20621 Pascal Way, Lake Forest, California 92630.
2.2 Traceability Statement
The calibration certificates of all test equipment used during the test are on file at the location of the
test. The calibration is traceable to the National Institute of Standards and Technology (NIST).
For equipment used for immunity testing, refer to the applicable calibration certificates for tolerance
and uncertainty information, which is on file at the location of the test.
2.3 Cognizant Personnel
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 10 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
3. APPLICABLE DOCUMENTS
The following documents are referenced or used in the preparation of this test report.
SPEC TITLE
ANSI C63.4: 2009 Methods of measurement of radio-noise emissions from low voltage electrical and
electronic equipment in the range of 9 kHz to 40GHz
CISPR 16-1-4 Specification for radio disturbance and immunity measuring apparatus and methods.
2010 Part 1-4 radio disturbance and immunity measuring apparatus – Ancillary Equipment
– Radiated Disturbances
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 11 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
SPEC TITLE
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 12 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
The EUT is setup in a tabletop configuration. The EUT is connected to the host desktop computer via
power and SATA III internally. The host desktop computer is connected to the monitor, switch,
keyboard, mouse, and microphone/headphone ports via video, Ethernet, PS/2, USB, and microphone
and headphone ports respectively. The EUT is being exercised by running an automated program that
writes data to the disk and reads the data and scans for errors. The automated program is set to loop
upon completion of the test.
The cables were moved to maximize the emissions. The final conducted and radiated data was taken
in the continuously exercising mode of operation. All initial investigations were performed with the
EMI Receiver in manual mode scanning the frequency range continuously. The cables were bundled
and routed as shown in the photographs in Appendix D.
4.1.1 Photograph of Test Configuration
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 13 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Cable 1
This is a 1.5 meter, braid shielded, video cable that connects the desktop computer to the monitor.
The cable has DVI connectors at each end. The cable is bundled to a length of 1 meter. The cable
has a molded ferrite on both the desktop computer end and the monitor end.
Cable 2
This is a 2 meter, unshielded, Ethernet cable that connects the desktop computer to the switch. The
cable has RJ-45 connectors at each end. The cable is bundled to a length of 1 meter.
Cable 3
This is a 1 meter, foil shielded, cable that connects the desktop computer to the keyboard. The cable
has PS/2 connector at the desktop computer end and is hardwired into the keyboard.
Cable 4
This is a 1 meter, foil shielded, cable that connects the desktop computer to the mouse. The cable has
USB connector at the desktop computer end and is hardwired into the mouse.
Cable 5
This is a 1 meter, unshielded, cable that connects the desktop computer to the microphone/headphone.
The cable has a 3.5mm phone jack connector at the desktop computer end and is hardwired into the
microphone/headphone.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 14 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
The EUT was operating as described in section 4.1 of this report. The EUT was observed for
susceptibility by monitoring the status of the read/write program.
4.2.1 Susceptibility Criteria
Electrostatic Discharge B
Radio-Frequency A
Electromagnetic Field
Fast Transients B
Common Mode
Conducted Disturbances A
Induced by RF Fields
Power Frequency A
Magnetic Field
Susceptibility
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 15 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Performance criteria B: The apparatus shall continue to operate as intended after the test. No
degradation of performance or loss of function is allowed below a performance level specified by the
manufacturer, when the apparatus is used as intended. In some cases the performance level may be
replaced by a permissible loss of performance. During the test, degradation of performance is
however allowed. No change of actual operating state or stored data is allowed. If the minimum
performance level or the permissible performance loss is not specified by the manufacturer then either
of these may be derived from the product description and documentation and what the user may
reasonably expect from the apparatus if used as intended.
Performance criteria C: Temporary loss of function is allowed, provided the loss of function is self-
recoverable or can be restored by the operation of the controls.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 16 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 17 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Mast, Antenna
Positioner Sunol Science Corporation SC104V 081309-1 N/A N/A
Antenna Mast Sunol Science Corporation TWR 95-4 081309-3 N/A N/A
Turntable Sunol Science Corporation FM2011VS NONE N/A N/A
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 18 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 19 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 20 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 21 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
The radiated emissions measurements were performed on a 10 meter Open Area Test Site. The
conducted emissions measurements were performed in a semi-anechoic chamber. All RF immunity
tests were performed in a shielded enclosure 23 feet wide, 23 feet long and 12 feet high. Please refer
to section 2.1 and 7.1.3 of this report for EMI test location.
For all tests except for ESD, EFT and the Conducted Immunity tests, the EUT was set up on a 1.0 by
1.5 by 0.8 meter high non-conductive table, which was placed on the ground plane. For ESD testing,
the unit was mounted 0.5 millimeters above the 0.8 meter by 1.6 meter horizontal coupling plane. For
the Conducted Immunity and EFT tests, the EUT was mounted 10cm above the GRP.
When applicable refer to the data sheets in Appendix E for the relative humidity, air temperature and
barometric pressure.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 22 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
7. TEST PROCEDURES
The following sections describe the test methods and the specifications for the tests. Test results are
also included in this section.
7.1 RF Emissions
7.1.1 Conducted Emissions Test
The EMI Receiver was used as a measuring meter. A 10 dB attenuation pad was used for the
protection of the EMI Receiver input stage. All factors associated with attenuator and cables were
recorded into the EMI Software Program accordingly to display the actual corrected measured level.
The LISN output was connected to the input of the EMI Receiver. The output of the second LISN
was terminated with 50-ohm termination. The effective measurement bandwidth used for the
conducted emissions test was 9 kHz.
Please see section 6.2 of this report for mounting, bonding and grounding of the EUT. The EUT was
powered through the LISN, which was bonded to the ground plane. The LISN power was filtered and
the filter was bonded to the ground plane. The EUT was set up with the minimum distances from any
conductive surfaces as specified in EN55032 and CISPR 22. The excess power cord was wrapped in
a figure eight pattern to form a bundle not exceeding 0.4 meters in length.
The initial test data was taken in manual mode while scanning the frequency ranges of 0.15 MHz to
30 MHz. The conducted emissions from the EUT were maximized for operating mode as well as
cable placement. Once a predominant frequency (within 12 dB of the limit) was found, it was more
closely examined with the spectrum analyzer span adjusted to 1 MHz.
The final data was collected under program control by the computer in several overlapping sweeps by
running the EMI Receiver at a minimum scan rate of 10 seconds per octave. The six highest
emissions are listed in Table 1 – Table 4.
Test Results:
The EUT had no telecommunication ports; therefore this test was deemed unnecessary and thus was
not performed beyond an exploratory test. Had this test been applicable it would have been
performed as described below.
The EMI Receiver was used as a measuring meter. All factors associated with attenuator and cables
were recorded into the EMI Software Program accordingly to display the actual corrected measured
level. The current probe output was read by the EMI Receiver. The effective measurement
bandwidth used for the conducted emissions test was 9 kHz. The initial test data was taken while
scanning the frequency ranges of 0.15 MHz to 30 MHz. The conducted emissions from the EUT
were maximized for operating mode as well as cable placement.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 23 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
The EMI Receiver was used as the measuring meter. A preamplifier was used to increase the
sensitivity of the instrument. The EMI Receiver was used in the Analyzer mode feature activated. In
this mode, the EMI receiver can then record the actual frequency to be measured. This final reading
is then taken accurately in the EMI Receiver mode, which takes into account the cable loss, amplifier
gain and antenna factors, so that a true reading is compared to the true limit. A quasi-peak reading
was taken only for those readings, which are marked accordingly on the data sheets. The effective
measurement bandwidth used for the radiated emissions test was according to the frequency measured
(120 kHz for 30 MHz to 1 GHz and 1 MHz for 1 GHz and above).
Broadband Combilog Antenna and horn antennas were used as transducers during the measurement.
The Combilog Antenna was used from 30 MHz to 1000 MHz and the horn was used above 1 GHz.
Furthermore, the frequency span was reduced during the preliminary investigations as deemed
necessary.
The open field test site of Compatible Electronics, Inc. was used for radiated emission testing from
30MHz to 1000MHz. The TDK FAC-3 shielded test chamber of Compatible Electronics, Inc. was
used for radiated emissions testing from 1GHz to 30GHz. This test site is set up according to CISPR
16. Please see section 6.2 of this report for mounting, bonding and grounding of the EUT. The
turntable supporting the EUT is remote controlled using a motor. The turntable permits EUT rotation
of 360 degrees in order to maximize emissions. Also, the antenna mast allows height variation of the
antenna from 1 meter to 4 meters. Data was collected in the worst case (highest emission)
configuration of the EUT. At each reading, the EUT was rotated 360 degrees and the antenna height
was varied from 1 to 4 meters (for E field radiated field strength).
The presence of ambient signals was verified by turning the EUT off. In case an ambient signal was
detected, the measurement bandwidth was reduced temporarily and verification was made that an
additional adjacent peak did not exist. This ensures that the ambient signal does not hide any
emissions from the EUT.
The EUT was tested at a 10 meter test distance from 30 MHz to 1 GHz, and at a 3 meter test distance
above 1 GHz to obtain final test data. The six highest emissions are listed in Table 5 - Table 8.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 24 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Notes:
* The complete emissions data is given in Appendix E of this report.
** The factors for the antenna and preamplifier gain are attached in Appendix D of this report.
# Quasi-Peak Reading
A Average Reading
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 25 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Notes:
* The complete emissions data is given in Appendix E of this report.
** The factors for the antenna and preamplifier gain are attached in Appendix D of this report.
# Quasi-Peak Reading
A Average Reading
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 26 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Notes:
* The complete emissions data is given in Appendix E of this report.
** The factors for the antenna and preamplifier gain are attached in Appendix D of this report.
# Quasi-Peak Reading
A Average Reading
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 27 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
An ESD Generator was used for this test. The characteristics consist of an energy storage capacitor:
150pF; discharge resistance: 330 Ohms; charging resistor: 100 Megaohms; tolerance of voltage
indication: +5%; polarity of output voltage: positive and negative. The waveshape conforms to EN
61000-4-2.
7.2.1 Direct ESD - Air Discharge
In the Air ESD test, the EUT was exposed to a direct air discharge at all user accessible surfaces. The
ESD arc was drawn directly to any insulated or conductive point on the EUT. The test simulated a
situation in which any person or object carrying an electrostatic charge discharges it to any point on
the equipment. The ground strap of the ESD generator was connected to the earth ground (shield
room ground reference plane) and was a minimum of 0.2 m away from the EUT.
Please see section 6.2 of this report for mounting, bonding and grounding of the EUT. The EUT was
operated and configured as described in section 4.2 of this report. The EUT was set up as shown in
Appendix D of this report. Photographs of the test equipment, and EUT setup during the test are in
Appendix D. The data sheets are in Appendix E.
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. The test point
locations were selected based on an exploratory test of inducing 20 discharges per second onto all
surfaces of the unit. The test point locations selected for the final test are listed in the data sheets
attached in Appendix E.
The test voltages were increased from 2.0 kV to 15.0 kV, in order to eliminate errors related to the
"window" effect associated with ESD testing. Also, testing in increments helps determine the voltage
threshold without severely damaging the unit. The final test was performed with 10 single shot
discharges on each selected point in each polarity. The rounded discharge probe was used for the test.
After completion of the test, a functional test was performed on the EUT to ensure proper operation.
Test Results:
The EUT complies with the relevant requirements of EN55024. The unit operates within the
specifications for air discharge at 2.0 kV, 4.0 kV, 6.0 kV, 8.0 kV, 12kV, and 15kV (insulated
surfaces).
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 28 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
In the contact ESD test, the EUT was exposed to a direct contact discharge at all conductive user
accessible surfaces. The ESD arc was drawn directly to any conductive point on the equipment under
test. The test provides a repeatable method to determine immunity of the EUT to electrostatic
discharges. The ground strap of the ESD generator was connected to the earth ground (shield room
ground reference plane) and was a minimum of 0.2 m away from the EUT.
Please see section 6.2 of this report for mounting, bonding and grounding of the EUT. The EUT was
operated and configured as described in section 4.2 of this report. The EUT was set up as shown in
Appendix D of this report. Photographs of the test equipment and EUT setup during the test are in
Appendix D. The data sheets are in Appendix E.
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. The test point
locations were selected based on the exploratory test of inducing 20 discharges per second onto all
surfaces of the unit. The test point locations selected for the final test are listed in the data sheets
attached in Appendix E.
The test voltages were 2.0 kV, 4.0 kV, and 8kV in order to eliminate errors related to the
"window" effect associated with ESD testing. Also, testing in increments helps determine the
threshold without severely damaging the unit. The final test was performed with single shot
discharges on all the selected points.
The pointed discharge probe was touching the conductive surface of the unit before initiating the
discharge. For painted surfaces, the sharp tip of the probe was used to penetrate the paint before
providing discharge to the EUT. At least 25 discharges (in both polarities) were applied at each test
point. After completion of the test, a functional test was performed on the EUT to ensure proper
operation.
Test Results:
The EUT complies with the relevant requirements of EN55024 as per the requirements described in
EN61000-4-2. The unit operates within the specifications for contact discharge at 2.0 kV 4.0 kV,
and 8kV (conductive surfaces).
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 29 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
For indirect electrostatic discharges, the vertical coupling plane (0.5 m x 0.5 m) was tied to the
ground reference plane through braid and a series of two 470 k resistors one at each end of the
braid.
Please see section 6.2 of this report for mounting, bonding and grounding of the EUT. The EUT was
operated and configured as described in section 4.2 of this report. The EUT was set up as shown in
Appendix D of this report. Photographs of the test equipment and EUT setup during the test are in
Appendix D. The data sheets are in Appendix E.
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. A distance of one
meter was maintained between the EUT and the shield room walls or any other metallic structures.
The ground strap of the ESD generator was connected to the earth ground (shield room ground
reference plane) and was a minimum of 0.2 m away from the EUT. The coupling plane was placed
0.1 meters from each side of the EUT, and at a height close to the center of the EUT. The discharges
were applied to the edge of the VCP. Ten discharges were applied to the VCP at each test level in
each polarity on each side of the unit. After completion of the test, a functional test was performed on
the EUT to ensure proper operation.
Test Results:
The EUT complies with the relevant requirements of EN55024 as per the requirements described in
EN61000-4-2. The unit operates within the specifications for indirect discharges to the VCP at 2.0
kV 4.0 kV, and 8kV.
For indirect electric discharges the horizontal coupling plane (1.0 m x 1.0 m) was tied to the ground
reference plane through braid and a series of two 470 k resistors at each end of the braid.
Please see section 6.2 of this report for mounting, bonding and grounding of the EUT. The EUT was
operated and configured as described in section 4.2 of this report. The EUT was set up as shown in
Appendix D of this report. Photographs of the test equipment and EUT setup during the test are in
Appendix D. The data sheets are in Appendix E.
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. A distance of one
meter was maintained between the EUT and the shield room walls or any other metallic structures.
The ground strap of the ESD generator was connected to the earth ground (shield room ground
reference plane) and was a minimum of 0.2 m away from the EUT. The discharges were applied to
the center of the front edge of the HCP 10cm in front of the EUT at each test level in each polarity.
After completion of the test, a functional test was performed on the EUT to ensure proper operation.
Test Results:
The EUT complies with the relevant requirements of EN55024 as per the requirements described in
EN61000-4-2. The unit operates within the specifications for indirect discharges to the HCP at 2.0
kV 4.0 kV, and 8kV.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 30 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
For this test, the Hybrid Log Periodic was used to radiate the energy onto the EUT at the specified
test level. The field uniformity was established by means of the computer software program prior to
the test and without injecting modulation. The transmitting antenna was placed in a fixed location
and distance during both calibration and test.
Please see section 6.2 of this report for mounting, bonding, and grounding of the EUT. The EUT was
operated and configured as described in section 4.2 of this report. The EUT was set up as shown in
Appendix D of this report. Photographs of the test equipment and EUT setup during the test are
included in Appendix D. The data sheets are located in Appendix E.
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. The RF energy was
radiated using the hybrid log from 80 - 2000 MHz. The signal was amplitude modulated at 80% with
a 1 kHz sine wave for the entire frequency range. The frequency was adjusted by 1% increments
beginning with the start frequency and increasing by 1% of each subsequent frequency, the dwell
time was 1 sec. In certain cases the dwell time may be extended due to the operating duty cycle of the
EUT, but in any event, the dwell time is sufficiently long to encompass the entire duty cycle of the
EUT.
A solitary probe was placed next to the EUT for field verification only. The computer software
program performed the test. After completion of the test, a functional test was performed on the EUT
to ensure proper operation.
Test Results:
The EUT complies with the relevant requirements of EN55024 as per the test procedures described in
EN 61000-4-3. The unit operates within the specifications.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 31 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
The test was performed as per EN 61000-4-4. The burst duration was 15 ms, with 300 ms burst
period. The individual impulse had a 5ns rise time and a 50ns decay time and a 5 kHz frequency up
to 2 kV, and a 2.5 kHz frequency above 2 kV. The EMC immunity test system was used for the test.
Please see section 6.2 of this report for mounting, bonding, and grounding of the EUT. The EUT was
operated and configured as described in section 4.2 of this report. The coupling/decoupling network
was placed 0.5 meter away from the EUT. The EUT was set up as shown in Appendix D of this
report. Photographs of the test equipment and EUT setup during the test are included in Appendix D.
7.4.1 Power Lines
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. The transient
energy was injected onto the power line through the use of a coupling/decoupling network. Bursts of
pulse trains were injected onto the power line, in both positive and negative polarities. The test level
was 0.5 kV and 1.0 kV. The test was run for one minute on each lead and each lead combination.
After completion of the test, a functional test was performed on the EUT to ensure proper operation.
Test Results:
The EUT complies with the relevant requirements of EN55024 as per the test procedures described in
EN 61000-4-4. The unit operates within specifications during and after bursts of transients of 0.5
kV and 1.0 kV on power lines.
7.4.2 Data Lines
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. The transient
energy was coupled from the EMC immunity test system to the signal lines through the use of the
capacitive coupling clamp. The clamp meets the requirements of EN 61000-4-4. The clamp was
placed on the ground plane, and the data lines were placed inside the clamp. Bursts of pulse trains
were injected onto the signal lines, in both positive and negative polarities. The test level was 0.5
kV. The test was run for one minute on each cable. After completion of the test, a functional test was
performed on the EUT to ensure proper operation.
Test Results:
The EUT complies with the relevant requirements of EN55024 as per the test procedures described in
EN 61000-4-4. The unit operates within specifications during and after bursts of transients of 0.5
kV on data lines.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 32 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Power Lines
The EMC Test Immunity System was used to provide the "Combination Wave" as specified in EN
61000-4-5 Voltage waveform for high impedance - Rise time to crest voltage: 1.2 uS approx. and
Decay: 50 uS to 50% of peak voltage value. Current waveform for low impedance - Rise time to crest
voltage: 8.0 uS approx. and Decay: 20 uS to 50% of peak current value. The amplitude was increased
incrementally at the stated test levels contained in EN 61000-4-5 using the EMC Test Immunity
System software, which was installed on the desktop computer. As per EN 61000-4-5, the selection
of the voltage or current waveform depends on impedance offered by the EUT.
Test Results:
The EUT complies with the requirements of EN55024 as per the test procedures described in EN
61000-4-5. The unit operates within its specifications before and after Common mode Surges of
2.0 kV and Differential mode surges of 1.0 kV on power lines.
Telecommunication Lines
Test Results:
The EUT has no telecommunication cables that connect directly to outdoor cables; therefore this test
was deemed unnecessary and thus was not performed. Had this test been applicable it would have
been performed as described below.
The EMC Test Immunity System was used to provide the "Combination Wave" as specified in EN
61000-4-5 Voltage waveform for high impedance - Rise time to crest voltage: 1.2 uS approx. and,
Decay: 50 uS to 50% of peak voltage value. Current waveform for low impedance - Rise time to crest
voltage: 8.0 uS approx. and, Decay: 20 uS to 50% of peak current value. The amplitude was
increased incrementally at the stated test levels contained in EN 61000-4-5 using the EMC Test
Immunity System software, which was installed on the desktop computer. Surges were initiated on
the telecommunication line through the external coupler/decoupler module from the EMC Test
Immunity System. The telecommunication lines test was performed as per EN 61000-4-5.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 33 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. This test was
performed as per EN 61000-4-6. For this test, a Coupling Decoupling Network was used to induce
an RF-field current directly onto the AC lines. The signal was 80% AM modulated with a 1 kHz sine
wave, with a field strength of 3Vrms, over the frequency range of 150 kHz to 80 MHz. The
frequency range was covered with a 1% step size and the dwell time was 1 second. The EUT was
placed 10 cm above the GRP with the Coupling Decoupling Network mounted and bonded to the
GRP.
The EUT was grounded through the AC power cord. The EUT was operated as described in section
4.2 of this report. The EUT was set up as shown in Appendix D of this report. Photographs of the
test equipment and EUT setup during the test are included in Appendix D.
Test Results:
The EUT complies with relevant requirements of EN55024 as per the test procedures described in EN
61000-4-6. The EUT operates within its specifications during exposure from 0.15 MHz - 80 MHz,
3Vrms with a 1 kHz sine wave AM modulation at 80%.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 34 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. This test was
performed to determine if the test sample was susceptible to Power Frequency Magnetic Fields which
are generated by power frequency current in conductors and leaking transformers. The test was
performed as per EN 61000-4-8. The magnetic field is applied by the immersion method to the EUT;
in this method the EUT is placed in the center of an induction coil. The waveform is that of the
typical power frequency either 50Hz or 60Hz. The Magnetic Field Strength is expressed in A/m; 1
A/m corresponds to free space induction of 1.26µTesla. A Square Induction coil, 1m by 1m with a
coupling plane placed under the EUT, was used to induce the magnetic field. The test duration was 1
minute for each of the three Orthogonal Axes.
Test Results:
The EUT complies with requirements of EN55024 as per the test procedures described in EN 61000-
4-8. The unit operates within its specifications before; during, and after the Power Magnetic Field of
3 A/m was applied.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 35 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Prior to the start of the test, a functional test was performed on the EUT to ensure proper operation.
The EUT was also monitored during the test for any degradation of performance. This test was
performed as per EN61000-4-11. The purpose of this test was to determine the immunity of the EUT
when subjected to voltage dips, short interruptions, and voltage variations. The voltages of the EUT
were varied and disrupted at various levels of the supplied voltages for a given period of time. At
each level the test was performed 3 times. The voltage change-overs took place at zero degree
crossings.
Test Results:
The EUT complies with requirements of EN55024 as per the test procedures described in EN 61000-
4-11. The unit operates within its specifications during and after voltage level reductions of >95% @
0.5 Period, 30% @ 30 Periods, and >95% @ 300 Periods.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 36 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Test Results:
The EUT is rated under 75W and is unlikely to cause voltage fluctuation or flicker; therefore this test
was not performed. Had this test been applicable it would have been performed as described below.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page 37 of 37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
9. CONCLUSIONS
The INTERNAL HARD DISK DRIVE, R/N: 800055, as tested, meets all of the Class B requirements
of the European Standards AS/NZS CISPR 32, ICES -003, VCCI, CNS13438, EN55032
(Electromagnetic compatibility of multimedia equipment – Emissions requirements) and EN55024
(Information Technology Equipment – Immunity Characteristics – Limits and Methods of
Measurement). Under paragraph G of section 15.109 of the Code of Federal Regulations Title 47,
Part 15, of the FCC Rules, the FCC accepts the international standards set forth in C.I.S.P.R.
Publication 22.
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page A1
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
APPENDIX A
LABORATORY ACCREDITATIONS
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page A2
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
"A laboratory's fulfilment of the requirements of ISO/IEC 17025:2005 means the laboratory meets both
the technical competence requirements and management system requirements that are necessary for it to
consistently deliver technically valid test results and calibrations. The management system requirements
in ISO/IEC 17025:2005 (Section 4) are written in language relevant to laboratory operations and meet the
principles of ISO 9001:2008 Quality Management Systems — Requirements."
Compatible Electronics has been nominated as a Conformity Assessment Body (CAB) for EMC under the
US/EU Mutual Recognition Agreement (MRA).
US/EU MRA list NIST MRA site
Compatible Electronics has been nominated as a Conformity Assessment Body (CAB) for Taiwan/BSMI
under the US/APEC (Asia-Pacific Economic Cooperation) Mutual Recognition Agreement (MRA).
APEC MRA list NIST MRA site
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page B1
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
APPENDIX B
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page B2
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page C1
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
APPENDIX C
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page C2
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D1
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
APPENDIX D
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D2
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
80 cm
TO EMI
RECEIVER
ACCESSORY EUT
POWER POWER
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D3
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
TURNTABLE
ANTENNA
3m
Mast, Antenna
Positioner
EMI Receiver
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D4
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D5
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D6
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
UNIFORM
WOODEN FIELD AREA
TEST BENCH
ANTENNA
ABSORBING
FERRITE
FERRITE TILES TO
REDUCE FLOOR
REFLECTIONS
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D7
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D8
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D9
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D10
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D11
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D12
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
COM-POWER AC-220
S/N: 25857
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D13
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
COM-POWER AH-118
HORN ANTENNA
S/N: 071250
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D14
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
COM-POWER PAM-118
1-18GHz - PREAMPLIFIER
S/N: 443013
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D15
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
FRONT VIEW
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D16
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
REAR VIEW
WESTERN DIGITAL CORP.
INTERNAL HARD DISK DRIVE
R/N: 800055
EN 55032 CLASS B - RADIATED EMISSIONS – 4-22-2016
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D17
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D18
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D19
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
FRONT VIEW
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D20
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
REAR VIEW
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D21
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
Pictures of 800055
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D22
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D23
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D24
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D25
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D26
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D27
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D28
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
ELECTROSTATIC DISCHARGE
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D29
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
ELECTROSTATIC DISCHARGE
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D30
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
ELECTROSTATIC DISCHARGE
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D31
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D32
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D33
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D34
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D35
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D36
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D37
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page D38
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E1
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
APPENDIX E
DATA SHEETS
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E2
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
ELECTROSTATIC DISCHARGE
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E3
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
ELECTROSTATIC DISCHARGE
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E4
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E5
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
TEST LEVEL (kV) TEST DURATION (minutes) TIME BETWEEN TESTS (seconds)
1.0 1.0 10.0
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E6
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
L1 & Ground 0 90 180 270 ±500 Passed Meets applicable performance criteria
L1 & Ground 0 90 180 270 ±1000 Passed Meets applicable performance criteria
L1 & Ground 0 90 180 270 ±2000 Passed Meets applicable performance criteria
L2 & Ground 0 90 180 270 ±500 Passed Meets applicable performance criteria
L2 & Ground 0 90 180 270 ±1000 Passed Meets applicable performance criteria
L2 & Ground 0 90 180 270 ±2000 Passed Meets applicable performance criteria
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E7
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
CONDUCTIVE DISTURBANCES
INDUCED BY RF ELECTROMAGNETIC FIELDS TEST
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E8
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E9
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
TEST LEVEL (%) NUMBER OF TEST REPETITIONS TIME BETWEEN TESTS (seconds)
>95%, 30 % 3 10.0
0.5 period >95 Passed (short circuit) Meets applicable performance criteria
300 periods >95 Passed (open circuit) EUT resumed normal operation after
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E10
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E11
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E12
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E13
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
(AVG) (AVG)EM
Limit (dB Ttbl Agl Transduce
Freq(MHz) Margi I Pol Twr Ht (cm)
V/m) (deg) r (dB)
n (dB) (dBµV/m)
1323.00 -3.29 46.71 50.00 H 313.00 181.41 29.69
2105.00 -14.58 35.42 50.00 H 10.25 128.64 32.76
2223.00 -13.65 36.35 50.00 H 280.25 103.82 33.78
2421.00 -8.37 41.63 50.00 H 298.25 128.05 35.35
2490.00 -7.98 42.02 50.00 H 17.25 106.41 35.87
2490.00 -9.22 40.78 50.00 V 61.00 104.11 35.88
2530.00 -9.69 40.31 50.00 H 313.25 106.94 35.80
2742.00 -10.85 39.15 50.00 H 360.00 160.35 34.76
3067.00 -14.60 39.40 54.00 V 290.50 99.70 34.01
3107.00 -17.56 36.44 54.00 H 26.25 130.88 34.24
3403.00 -14.70 39.30 54.00 H 19.25 128.52 35.91
3506.00 -14.49 39.51 54.00 V 267.00 212.11 36.42
3716.00 -14.84 39.16 54.00 H 319.00 146.88 36.17
4992.00 -9.83 44.17 54.00 H 325.75 163.00 40.05
5199.00 -10.68 43.32 54.00 V 197.75 200.58 39.54
5620.00 -10.74 43.26 54.00 V 234.50 182.70 38.86
5749.00 -10.42 43.58 54.00 H 272.75 350.00 39.02
5987.00 -8.79 45.21 54.00 H 343.50 219.88 39.32
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E14
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E15
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
(AVG) (QP)
(AVG) (AVG) (QP)
Freq Margin Margin (QP) EMI Transduce
EMI Limit Limit
(MHz) AVL QPL (dBuV) r (dB)
(dBuV) (dBuV) (dBuV)
(dB) (dB)
0.43 -25.76 -17.22 21.49 40.03 47.25 57.25 0.07
0.45 -24.14 -15.86 22.81 41.09 46.95 56.95 0.07
0.47 -16.34 -13.53 30.18 42.98 46.51 56.51 0.07
0.48 -18.51 -14.07 27.87 42.31 46.37 56.37 0.07
0.49 -18.33 -13.35 27.91 42.89 46.24 56.24 0.07
0.49 -17.90 -12.42 28.20 43.68 46.10 56.10 0.07
0.94 -21.77 -20.80 24.23 35.20 46.00 56.00 0.07
1.15 -27.79 -20.50 18.21 35.50 46.00 56.00 0.07
1.16 -23.18 -19.74 22.82 36.26 46.00 56.00 0.07
1.17 -23.39 -18.51 22.61 37.49 46.00 56.00 0.07
1.18 -24.58 -18.63 21.42 37.37 46.00 56.00 0.07
1.24 -23.35 -15.84 22.65 40.16 46.00 56.00 0.07
1.53 -22.52 -17.27 23.48 38.73 46.00 56.00 0.07
1.60 -23.22 -19.48 22.78 36.52 46.00 56.00 0.07
1.68 -22.82 -17.73 23.18 38.27 46.00 56.00 0.07
1.70 -24.05 -18.43 21.95 37.57 46.00 56.00 0.07
1.71 -23.89 -19.48 22.11 36.52 46.00 56.00 0.07
1.97 -23.08 -21.20 22.92 34.80 46.00 56.00 0.07
2.48 -24.79 -19.68 21.21 36.32 46.00 56.00 0.07
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E16
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E17
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
(AVG) (QP)
(AVG) (AVG) (QP)
Freq Margin Margin (QP) EMI Transduce
EMI Limit Limit
(MHz) AVL QPL (dBuV) r (dB)
(dBuV) (dBuV) (dBuV)
(dB) (dB)
0.47 -14.79 -11.75 31.66 44.70 46.44 56.44 0.03
0.49 -14.79 -10.58 31.44 45.66 46.24 56.24 0.03
0.49 -11.36 -10.55 34.74 45.55 46.10 56.10 0.03
0.51 -13.98 -12.18 32.02 43.82 46.00 56.00 0.03
0.65 -22.72 -16.69 23.28 39.31 46.00 56.00 0.01
0.96 -19.90 -14.08 26.10 41.92 46.00 56.00 0.00
1.01 -20.38 -14.22 25.62 41.78 46.00 56.00 0.00
1.15 -24.36 -16.76 21.64 39.24 46.00 56.00 0.00
1.18 -19.73 -13.41 26.27 42.59 46.00 56.00 0.00
1.19 -19.64 -12.48 26.36 43.52 46.00 56.00 0.00
1.20 -19.19 -12.11 26.81 43.89 46.00 56.00 0.00
1.21 -17.72 -11.25 28.28 44.75 46.00 56.00 0.00
1.23 -18.02 -11.38 27.98 44.62 46.00 56.00 0.00
1.23 -19.13 -11.25 26.87 44.75 46.00 56.00 0.00
1.25 -18.09 -12.66 27.91 43.34 46.00 56.00 0.00
1.27 -18.39 -13.03 27.61 42.97 46.00 56.00 0.00
1.51 -22.16 -16.92 23.84 39.08 46.00 56.00 0.01
1.63 -22.75 -19.84 23.25 36.16 46.00 56.00 0.01
1.64 -20.31 -16.39 25.69 39.61 46.00 56.00 0.01
1.65 -20.39 -14.69 25.61 41.31 46.00 56.00 0.01
1.68 -22.41 -15.74 23.59 40.26 46.00 56.00 0.01
1.71 -19.90 -13.18 26.10 42.82 46.00 56.00 0.01
1.74 -17.56 -11.35 28.44 44.65 46.00 56.00 0.01
1.77 -21.49 -14.79 24.51 41.21 46.00 56.00 0.01
1.77 -22.13 -15.53 23.87 40.47 46.00 56.00 0.01
1.82 -20.62 -15.81 25.38 40.19 46.00 56.00 0.01
1.91 -21.83 -16.07 24.17 39.93 46.00 56.00 0.01
1.93 -22.55 -15.45 23.45 40.55 46.00 56.00 0.01
1.95 -21.11 -14.12 24.89 41.88 46.00 56.00 0.01
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E18
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E19
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E20
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
(AVG) (QP)
(AVG) (AVG) (QP)
Freq Margin Margin (QP) EMI Transduce
EMI Limit Limit
(MHz) AVL QPL (dBuV) r (dB)
(dBuV) (dBuV) (dBuV)
(dB) (dB)
0.46 -20.54 -16.20 26.12 40.45 46.66 56.66 0.07
0.49 -15.97 -16.05 30.27 40.19 46.24 56.24 0.07
0.49 -17.82 -16.99 28.28 39.11 46.10 56.10 0.07
0.50 -16.80 -16.93 29.20 39.07 46.00 56.00 0.07
0.51 -14.88 -13.87 31.12 42.13 46.00 56.00 0.07
0.52 -14.62 -11.77 31.38 44.23 46.00 56.00 0.07
0.53 -14.57 -13.14 31.43 42.86 46.00 56.00 0.07
0.67 -21.79 -17.65 24.21 38.35 46.00 56.00 0.07
0.79 -19.31 -19.90 26.69 36.10 46.00 56.00 0.07
1.00 -21.08 -17.69 24.92 38.31 46.00 56.00 0.07
1.01 -19.94 -17.40 26.06 38.60 46.00 56.00 0.07
1.03 -19.16 -17.41 26.84 38.59 46.00 56.00 0.07
1.05 -18.44 -16.36 27.56 39.64 46.00 56.00 0.07
1.06 -18.20 -16.11 27.80 39.89 46.00 56.00 0.07
1.07 -18.21 -16.55 27.79 39.45 46.00 56.00 0.07
1.09 -19.47 -17.67 26.53 38.33 46.00 56.00 0.07
1.20 -22.05 -23.05 23.95 32.95 46.00 56.00 0.07
1.25 -22.22 -19.21 23.78 36.79 46.00 56.00 0.07
1.27 -20.85 -19.01 25.15 36.99 46.00 56.00 0.07
1.29 -21.47 -17.83 24.53 38.17 46.00 56.00 0.07
1.30 -21.39 -18.73 24.61 37.27 46.00 56.00 0.07
1.32 -21.42 -18.51 24.58 37.49 46.00 56.00 0.07
1.76 -16.34 -14.20 29.66 41.80 46.00 56.00 0.07
1.77 -19.04 -18.91 26.96 37.09 46.00 56.00 0.07
1.85 -20.09 -19.35 25.91 36.65 46.00 56.00 0.07
1.88 -20.95 -18.95 25.05 37.05 46.00 56.00 0.07
2.03 -20.62 -21.66 25.38 34.34 46.00 56.00 0.07
2.19 -22.04 -23.23 23.96 32.77 46.00 56.00 0.07
2.63 -21.34 -21.37 24.66 34.63 46.00 56.00 0.07
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E21
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E22
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
(AVG) (QP)
(AVG) (AVG) (QP)
Freq Margin Margin (QP) EMI Transduce
EMI Limit Limit
(MHz) AVL QPL (dBuV) r (dB)
(dBuV) (dBuV) (dBuV)
(dB) (dB)
0.34 -20.05 -14.21 29.10 44.95 49.15 59.15 0.04
0.47 -18.29 -16.12 28.22 40.39 46.51 56.51 0.03
0.49 -17.81 -16.76 28.29 39.34 46.10 56.10 0.03
0.52 -14.19 -11.83 31.81 44.17 46.00 56.00 0.03
0.83 -16.77 -14.80 29.23 41.20 46.00 56.00 0.00
1.04 -18.55 -16.53 27.45 39.47 46.00 56.00 0.00
1.05 -18.00 -15.84 28.00 40.16 46.00 56.00 0.00
1.07 -17.98 -15.37 28.02 40.63 46.00 56.00 0.00
1.13 -17.64 -17.12 28.36 38.88 46.00 56.00 0.00
1.14 -17.40 -17.05 28.60 38.95 46.00 56.00 0.00
1.16 -15.78 -13.82 30.22 42.18 46.00 56.00 0.00
1.17 -12.73 -8.88 33.27 47.12 46.00 56.00 0.00
1.62 -20.81 -19.62 25.19 36.38 46.00 56.00 0.01
1.77 -17.56 -16.51 28.44 39.49 46.00 56.00 0.01
2.62 -21.23 -21.13 24.77 34.87 46.00 56.00 0.01
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E23
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E24
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
(AVG) (QP)
(AVG) (AVG) (QP)
Freq Margin Margin (QP) EMI Transduce
EMI Limit Limit
(MHz) AVL QPL (dBuV) r (dB)
(dBuV) (dBuV) (dBuV)
(dB) (dB)
0.39 -27.38 -15.53 20.60 42.45 47.98 57.98 0.07
0.41 -21.67 -15.80 25.97 41.85 47.65 57.65 0.07
0.43 -22.73 -14.69 24.60 42.64 47.33 57.33 0.07
0.44 -21.78 -12.31 25.32 44.79 47.10 57.10 0.07
0.45 -20.94 -10.33 25.86 46.48 46.80 56.80 0.07
0.47 -18.81 -9.31 27.70 47.20 46.51 56.51 0.07
0.48 -18.86 -9.42 27.44 46.88 46.30 56.30 0.07
0.49 -18.15 -9.43 27.95 46.67 46.10 56.10 0.07
0.51 -15.42 -8.27 30.58 47.73 46.00 56.00 0.07
0.53 -14.75 -7.64 31.25 48.36 46.00 56.00 0.07
0.55 -11.09 -5.79 34.91 50.21 46.00 56.00 0.07
0.56 -9.87 -5.71 36.13 50.29 46.00 56.00 0.07
0.57 -8.37 -4.60 37.63 51.40 46.00 56.00 0.07
0.60 -15.24 -9.11 30.76 46.89 46.00 56.00 0.07
0.61 -13.83 -7.51 32.17 48.49 46.00 56.00 0.07
0.61 -16.67 -6.14 29.33 49.86 46.00 56.00 0.07
0.61 -17.61 -7.52 28.39 48.48 46.00 56.00 0.07
0.63 -18.46 -12.02 27.54 43.98 46.00 56.00 0.07
0.64 -21.83 -12.75 24.17 43.25 46.00 56.00 0.07
0.65 -21.26 -11.37 24.74 44.63 46.00 56.00 0.07
0.67 -21.33 -11.71 24.67 44.29 46.00 56.00 0.07
0.68 -21.31 -11.82 24.69 44.18 46.00 56.00 0.07
0.69 -21.22 -11.72 24.78 44.28 46.00 56.00 0.07
0.71 -21.36 -11.58 24.64 44.42 46.00 56.00 0.07
0.73 -20.52 -11.54 25.48 44.46 46.00 56.00 0.07
0.73 -21.28 -11.41 24.72 44.59 46.00 56.00 0.07
0.76 -21.07 -12.17 24.93 43.83 46.00 56.00 0.07
0.78 -20.33 -11.81 25.67 44.19 46.00 56.00 0.07
0.79 -19.80 -12.54 26.20 43.46 46.00 56.00 0.07
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E25
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E26
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E27
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
(AVG) (QP)
(AVG) (AVG) (QP)
Freq Margin Margin (QP) EMI Transduce
EMI Limit Limit
(MHz) AVL QPL (dBuV) r (dB)
(dBuV) (dBuV) (dBuV)
(dB) (dB)
0.39 -26.31 -14.57 21.76 43.49 48.06 58.06 0.03
0.42 -22.12 -15.14 25.29 42.27 47.41 57.41 0.03
0.43 -21.88 -12.69 25.30 44.48 47.18 57.18 0.03
0.45 -20.46 -10.46 26.42 46.42 46.88 56.88 0.03
0.47 -18.48 -9.58 28.10 47.00 46.58 56.58 0.03
0.48 -18.75 -9.40 27.56 46.91 46.30 56.30 0.03
0.49 -18.05 -9.37 28.05 46.73 46.10 56.10 0.03
0.51 -15.68 -8.29 30.32 47.71 46.00 56.00 0.03
0.52 -15.29 -7.92 30.71 48.08 46.00 56.00 0.03
0.54 -13.29 -7.14 32.71 48.86 46.00 56.00 0.02
0.55 -11.62 -6.08 34.38 49.92 46.00 56.00 0.02
0.56 -9.39 -6.42 36.61 49.58 46.00 56.00 0.02
0.57 -8.97 -5.24 37.03 50.76 46.00 56.00 0.02
0.57 -8.83 -4.83 37.17 51.17 46.00 56.00 0.02
0.58 -10.41 -7.28 35.59 48.72 46.00 56.00 0.02
0.59 -14.35 -9.80 31.65 46.20 46.00 56.00 0.02
0.60 -16.13 -8.69 29.87 47.31 46.00 56.00 0.02
0.61 -12.57 -6.22 33.43 49.78 46.00 56.00 0.02
0.62 -19.27 -13.45 26.73 42.55 46.00 56.00 0.01
0.64 -21.96 -12.99 24.04 43.01 46.00 56.00 0.01
0.65 -22.12 -11.40 23.88 44.60 46.00 56.00 0.01
0.67 -20.96 -11.77 25.04 44.23 46.00 56.00 0.01
0.68 -21.26 -11.86 24.74 44.14 46.00 56.00 0.01
0.69 -21.24 -11.75 24.76 44.25 46.00 56.00 0.01
0.71 -21.39 -11.66 24.61 44.34 46.00 56.00 0.00
0.72 -20.93 -11.59 25.07 44.41 46.00 56.00 0.00
0.73 -21.00 -11.33 25.00 44.67 46.00 56.00 0.00
0.75 -21.23 -11.96 24.77 44.04 46.00 56.00 0.00
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E28
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E29
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E30
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
(AVG) (QP)
(AVG) (AVG) (QP)
Freq Margin Margin (QP) EMI Transduce
EMI Limit Limit
(MHz) AVL QPL (dBuV) r (dB)
(dBuV) (dBuV) (dBuV)
(dB) (dB)
0.39 -26.72 -14.86 21.26 43.12 47.98 57.98 0.07
0.41 -19.54 -14.94 28.03 42.63 47.57 57.57 0.07
0.46 -20.93 -10.31 25.80 46.42 46.73 56.73 0.07
0.48 -20.96 -10.58 25.41 45.80 46.37 56.37 0.07
0.49 -19.10 -9.78 27.07 46.38 46.17 56.17 0.07
0.50 -18.56 -9.21 27.47 46.82 46.03 56.03 0.07
0.51 -16.97 -8.59 29.03 47.41 46.00 56.00 0.07
0.52 -16.23 -8.06 29.77 47.94 46.00 56.00 0.07
0.53 -14.50 -7.38 31.50 48.62 46.00 56.00 0.07
0.55 -13.17 -6.53 32.83 49.47 46.00 56.00 0.07
0.56 -12.17 -5.88 33.83 50.12 46.00 56.00 0.07
0.57 -11.58 -5.90 34.42 50.10 46.00 56.00 0.07
0.57 -13.80 -6.14 32.20 49.86 46.00 56.00 0.07
0.59 -15.94 -9.67 30.06 46.33 46.00 56.00 0.07
0.61 -12.39 -4.42 33.61 51.58 46.00 56.00 0.07
0.62 -9.95 -3.51 36.05 52.49 46.00 56.00 0.07
0.64 -15.44 -8.29 30.56 47.71 46.00 56.00 0.07
0.66 -19.97 -12.28 26.03 43.72 46.00 56.00 0.07
0.67 -21.24 -12.46 24.76 43.54 46.00 56.00 0.07
0.68 -22.68 -12.62 23.32 43.38 46.00 56.00 0.07
0.69 -23.05 -12.68 22.95 43.32 46.00 56.00 0.07
0.70 -23.74 -12.58 22.26 43.42 46.00 56.00 0.07
0.71 -23.24 -12.36 22.76 43.64 46.00 56.00 0.07
0.73 -22.82 -12.05 23.18 43.95 46.00 56.00 0.07
0.74 -22.22 -11.96 23.78 44.04 46.00 56.00 0.07
0.75 -20.77 -11.62 25.23 44.38 46.00 56.00 0.07
0.77 -21.68 -12.05 24.32 43.95 46.00 56.00 0.07
0.77 -20.40 -11.85 25.60 44.15 46.00 56.00 0.07
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E31
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E32
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E33
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
(AVG) (QP)
(AVG) (AVG) (QP)
Freq Margin Margin (QP) EMI Transduce
EMI Limit Limit
(MHz) AVL QPL (dBuV) r (dB)
(dBuV) (dBuV) (dBuV)
(dB) (dB)
0.37 -28.72 -15.86 19.69 42.55 48.41 58.41 0.03
0.39 -27.57 -14.99 20.49 43.07 48.06 58.06 0.03
0.41 -22.91 -15.47 24.82 42.26 47.73 57.73 0.03
0.42 -19.64 -14.78 27.85 42.71 47.49 57.49 0.03
0.43 -21.79 -14.45 25.46 42.80 47.25 57.25 0.03
0.44 -21.89 -11.69 25.14 45.33 47.02 57.02 0.03
0.45 -21.13 -10.27 25.67 46.53 46.80 56.80 0.03
0.46 -20.31 -10.19 26.34 46.47 46.66 56.66 0.03
0.47 -19.70 -10.33 26.82 46.19 46.51 56.51 0.03
0.48 -21.22 -10.56 25.16 45.82 46.37 56.37 0.03
0.49 -18.39 -9.45 27.71 46.65 46.10 56.10 0.03
0.51 -16.91 -8.57 29.09 47.43 46.00 56.00 0.03
0.52 -15.84 -8.09 30.16 47.91 46.00 56.00 0.03
0.53 -14.53 -7.32 31.47 48.68 46.00 56.00 0.03
0.54 -14.20 -7.35 31.80 48.65 46.00 56.00 0.02
0.55 -12.58 -6.39 33.42 49.61 46.00 56.00 0.02
0.57 -11.44 -5.97 34.56 50.03 46.00 56.00 0.02
0.57 -13.67 -7.04 32.33 48.96 46.00 56.00 0.02
0.59 -16.46 -10.29 29.54 45.71 46.00 56.00 0.02
0.61 -13.01 -4.62 32.99 51.38 46.00 56.00 0.02
0.62 -10.17 -3.62 35.83 52.38 46.00 56.00 0.01
0.63 -19.56 -6.98 26.44 49.02 46.00 56.00 0.01
0.64 -16.44 -9.47 29.56 46.53 46.00 56.00 0.01
0.65 -17.93 -12.33 28.07 43.67 46.00 56.00 0.01
0.67 -22.31 -12.63 23.69 43.37 46.00 56.00 0.01
0.69 -23.27 -12.61 22.73 43.39 46.00 56.00 0.01
0.71 -23.47 -12.55 22.53 43.45 46.00 56.00 0.00
0.73 -22.26 -11.97 23.74 44.03 46.00 56.00 0.00
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476
Page E34
FCC, ICES-003, VCCI, CNS13438, AS/NZS CISPR 22, EN55032 & EN55024 Report Number: D60422Q3
20621 PASCAL WAY, LAKE FOREST, CALIFORNIA, 92630 PH: (949) 587-0400 FX: (949) 587-0476