Professional Documents
Culture Documents
MB Switch
MB Switch
98
MODEL 210
with CODE (979) Special protection version
with CODE (Z04) Light armoring
with CODE (Z06) B6 armoring
P40.20-0267-01 P40.20-0272-01
g Inspect
1.1 Check vehicle ride height at front and rear. i With Mercedes-Benz measuring device. AR40.20-P-0300FB
1.2 Check vehicle level at front and rear axle with i With electronic inclination measuring device AR40.20-P-0301FB
electronic inclination measuring instrument and
adjust, if necessary
2 Inspect oil level of level control. Correct if necessary. AP32.30-P-3211BB
3 Pull down rear of vehicle to the specified control i Suspend the tie rod (040b) and the mounting
point (simulate laden vehicle). bolt (040g) on the frame floor on the rear mount of
the rear axle carrier and lock in position (arrows).
Place the measuring device on the inside of the
spring link.
l Pulling device *201589113100
l Measuring device *201589012100
i The control point can also be determined using
the electronic inclinometer
k Electronic clinometer (CM 9606) *WH58.30-Z-1001-31A
Control point in mm *BE40.20-P-1001-04A
Control point in ° *BE40.20-P-1002-04A
Adjusting
4 Push 4 mm drift in through the hole (arrow) in the When the adjustment is correct the drift can be
adjusting lever (3a) of the level controller (3) and inserted in the alignment socket in the suspension-
pull out. control unit.
If the adjustment is defective, loosen the adjusting
device of the link rod (55a). Fix the adjusting lever
(3a) of the level controller (3) in position with 4 mm
drift through the hole (arrow) and tighten adjusting
device of the link rod.
Copyright Dai mlerChrysler AG 08.04.2013 CD-Ausgabe G/02/05 . This WIS print-out w ill not be recorded by Modification services. Page 1
201 589 11 31 00 201 589 01 21 00
Copyright Dai mlerChrysler AG 08.04.2013 CD-Ausgabe G/02/05 . This WIS print-out w ill not be recorded by Modification services. Page 2