Professional Documents
Culture Documents
________________________________________________________________________________
BRIO – BRIO 2
COMPRESSOR CLEANING
In Brio and Brio 2 it is not present the Level Sensor in the waste tank.
In case of liquid inside the compressor it comes dirty under the metallic spring. This affect
the right performance of the system.
In case of leakage form the needle chamber and the washer manifold at the same time the
problem could be the lower efficiency of the compressor.
In order to reset the system in the right way it is necessary to clean the compressor.
Please follow the instruction below reported.
Cleaning instructions
1/8
Brio - Brio 2 Compressor Cleaning
________________________________________________________________________________
2) remove the top of the compressor paying attention to how it was positioned.
2/8
Brio - Brio 2 Compressor Cleaning
________________________________________________________________________________
4) our target is to remove and clean the metallic spring in the picture and clean it and the
bottom side.
3/8
Brio - Brio 2 Compressor Cleaning
________________________________________________________________________________
4/8
Brio - Brio 2 Compressor Cleaning
________________________________________________________________________________
6) clean by oil (for mechanical application) using a paper towel the parts indicated in the
picture that are in contact and wait that it is rightly dry.
5/8
Brio - Brio 2 Compressor Cleaning
________________________________________________________________________________
7) reassembly all the parts in the same way like shown in the below pictures.
6/8
Brio - Brio 2 Compressor Cleaning
________________________________________________________________________________
7/8
Brio - Brio 2 Compressor Cleaning
________________________________________________________________________________
Claudio Ciccone
International Sales Specialist
8/8