Professional Documents
Culture Documents
ECE Superbook by J. Ampoloquio Answer Key
ECE Superbook by J. Ampoloquio Answer Key
33. A. gilbert
Past & Possible 34. B. ampere-turn/weber
The Author
62. C.
life
reverse-breakdown voltage
Quiz 22
1. C. 2.1 mV/°C
63. A. 0.005
2. B. I, III, and IV
64. B. Rectifier
3. C. 3
65. D. A or C
4. D. the coupling capacitors
66. A. Half-wave rectifier
5. B. Beta
67. D. diode
6. D. amplifier applications
68. B. Increases 7. C. Frequency multipliers
69. A. One 8. A. Class A amplifiers
70. D. all of these 9. A. Q-point on a transistor collector
71. C. Varactor diode curves
72. D. I, III, and IV 10. A. Input voltage
73. B. 5.0 V 11. C. RF voltage amplifier
74. A. Decreases 12. A. Beta increases
75. A. Most positive 13. C. Below saturation and above
76. C. Bridge rectifier cutoff
77. B. increases 14. C. An rf voltage amplifier
78. D. As a VHF and UHF mixers and 15. A. unity-gain frequency
detectors 16. A. The amount of time (in relation
79. A. Half-wave rectifier to the input signal) that current
80. A. Voltage regulator flows in the output circuit
81. D. changes in output voltage and 17. C. To establish a proper stable dc
input voltage operating point
82. B. Light waves 18. C. No current flows from emitter
83. D. 41.7 mV to collector
84. A. a small value series resistor 19. B. 0.4 A
85. B. changes in load current and 20. D. It decreases
output voltage 21. A. very low
86. C. thermistor 22. B. Common collector
87. C. 4A 23. B. the transistor may be driven
88. B. 2 into saturation
89. A. 0.7 V 24. B. Smaller than the output current
90. C. Bridge rectifier 25. A. 0.96
91. C. 28.3 V 26. D. thin, lightly doped
92. C. Voltage controlled capacitor 27. B. To transfer energy from one
93. C. 32.4 V stage to another
conduction mode, but the gate 10. B. Uses a toothed iron wheel for
cannot be used to turn it off the rotor
60. C. A positive voltage on the gate 11. D. Combines the features of the
switches the SCR into permanent magnet and
conduction mode, but the gate variable reluctance
cannot be used to turn it off stepper motors
61. C. Light activated SCR 12. C. Be able to reverse polarity to
62. B. breakover voltage the same coils in sequence
63. A. Voltage gradient 13. B. Send the voltage to each
64. D. Latch individual field coil in sequence
65. D. Digital displays 14. D. Open-loop
66. A. Breakover 15. D. A control system where
67. C. show high resistance in both feedback is not used
directions 16. A. A control system that has a
68. C. show high resistance in both feedback loop
directions 17. B. Time lag
69. C. 2.5 V 18. A. A number which describes the
70. B. 0.7 V behavior of a device (output
71. A. SCS divided by the input)
72. C. Low-current drop out 19. D. 0.005V/rpm
73. C. capacitance 20. B. Any control system that uses a
74. B. False triggering digital circuit (such as a
75. A. dV/dt microprocessor) for the
76. C. pnpn diode controller
77. B. Transducers 21. A. A control system used in
78. A. High frequencies industry to oversee the making
79. B. Positive feedback of a uniform product
80. A. Degenerative or negative 22. D. A process that has a defined
feedback series of tasks
23. C. A closed-loop control system
Section 11 that physically moves
something
Fundamentals of Robotics 24. A. Differential synchro
Quiz 33 25. A. A system for automatically
1. D. 60 degrees machining parts on lathes and
2. C. Leon Fourcault milling machines
3. B. Uses a permanent magnet for 26. D. A simple robot that moves
the rotor parts from one place to
4. C. The torque required to rotate another, over and over
the shaft when it is stopped 27. D. Weld interval
with power off 28. A. Front-panel milking
5. C. Has only two separate winding 29. B. piezoelectric effect
circuits 30. A. Will reject frequencies below
6. B. Has four field coils, each coil is the cutoff frequency
energized separately 31. B. A, B and C
7. A. Frequency and induction 32. B. The information is conveyed by
heating current (to avoid voltage drop
8. A. When adjacent coil field coils problems)
are energized at the same time, 33. A. When equipment is grounded
causing the rotor to align at different places, which may
between the field coils cause a large current in the
9. D. Pneumatic and jointed arm shield
34. D. Stabilized
59. A.
address register to keep track
PROMs
Quiz 35
1. D. look-up table
60. B. number of bits in the address
2. C. carry chains
bus
3. D. 32
61. C. 65,536 locations
4. D. terminal count
62. A. inverting buffer
5. B. 9
63. A. stores the address of the
6. B. 9
instruction being fetched from
7. B. 2n
memory
8. B. Moore machine
64. A. stores the memory location of
9. D. enumerated type
data stored to be next worked
10. C. the output was previously 1,
on
and J = 1
65. B. machine language
11. B. 5
66. D. all of these
12. D. Both column and row decoders
67. B. store
13. A. fan-out
68. B. add, subtract increment or
14. A. VOH – VIH
decrement data
15. D. all of these
69. C. control input and output
16. A. Flowchart
devices
17. B. compare two numbers
70. A. design engineer
18. C. 1 if both inputs are the same
71. C. synthesis
19. B. AND gate
72. B. minterm
20. A. CMOS
73. A. data processing
21. C. open collector
74. C. 6
22. D. floating
75. A. Associative
23. B. settling time
76. B. hardware
24. D. digital
77. C. 16
25. A. ½ LSB
78. D. Database
26. D. nonmonotonic error
79. A. primitive
27. B. aliasing
80. B. VHDL
28. B. 1024
81. B. Operating system
29. B. Moore's Law
82. C. architecture