1. This distillation still head design is based on a Nixon/Stone setup and is made of copper with five different diameters of tubing.
2. It consists of a 1.5 inch condensing tube surrounded by a 2 inch external cooling tube and a 1 inch internal cooling tube to utilize the same water source for cooling.
3. A key aspect is altering fittings by filing away internal stops to allow tubes to pass through and create the external jacket.
1. This distillation still head design is based on a Nixon/Stone setup and is made of copper with five different diameters of tubing.
2. It consists of a 1.5 inch condensing tube surrounded by a 2 inch external cooling tube and a 1 inch internal cooling tube to utilize the same water source for cooling.
3. A key aspect is altering fittings by filing away internal stops to allow tubes to pass through and create the external jacket.
1. This distillation still head design is based on a Nixon/Stone setup and is made of copper with five different diameters of tubing.
2. It consists of a 1.5 inch condensing tube surrounded by a 2 inch external cooling tube and a 1 inch internal cooling tube to utilize the same water source for cooling.
3. A key aspect is altering fittings by filing away internal stops to allow tubes to pass through and create the external jacket.
different diameters of tubing Refracting Still- in its construction (2”, 1.5”, 1”, . 75” and .5”). Head Design It consists of a 1.5 inch condensing tube (Red) that is jacketed with a 2 inch cooling tube (yellow) and inserted with an additional 1 inch cooling tube (blue). COOLING WATER IN The internal (blue) and external (yellow) cooling units THERMO are joined together and utilize METER the same water source. The internal unit in capped on the bottom and has a 1”x.5”x.5” tee at the top. One arm of this tee is the cooling water inlet. The other tee has a length of . 5 inch tubing running through it. This outlet tube runs from the bottom of this unit up through the tee where it is TO THE soldered to the discharge hose STILL DISTILLATE fitting. OUT A key to the construction of this unit is the alteration of fittings. Normally, these fittings have internal stops that prevent a tube from extended too far into the fitting. In order to allow the tubes to pass through the fittings so as to create the external jacket these stops are filed away.
The upper end of the
condensing tube (red) is left open to prevent pressure build up.