Professional Documents
Culture Documents
Course: MGT314
Section: 6
Group: 5
Submitted to:
Md. Mofassel Hossain
Department of Management
Submitted By:
Group Members ID
MD.Solaiman 1812181630
Step-1: raw water is collected in the tank. An available quantity is tapped into the above tank
where water is mixed with alum to solidify with sufficient metal or inexplicable problems.
Step-2: After the quartz sand filter is allowed to form due to the water with a few minutes.
Uncleanness can be eliminated through reverse osmosis method. Supernatant water is transported
to the activated carbon filter tank where the essential sterilization is done by perforating the
chlorine gas.
Step-3: The water then passes through the fish filter channel to capture the dissolved
contaminants. After filtration, water passes through carbon channels for odor, shade and
chlorination.
Step-4: It then goes through a series of contained miniature fillers. The last advance is pressed.
Step-5: Prerequisite is pressed through a programmed washing, filling and covering machine
attached to the ozone generator. The containers are then wrapped and stuffed into a dozen
layered boxes. In addition to untreated water, other natural substances are needed in synthetics,
reagents, pockets, containers, and outdoor. In a mineral water plant, the main required utility is
electricity.
Our automation machine can make 160units per day in 8-hour workday
Raw water Quartz sand Carbon Pumping Gas water Final water
tank filter filter mix product
Workstatio Workstation Workstation Workstation Workstation
n1 2 3 4 5
3 minutes 3 minutes 3 minutes 3 minutes 3 minutes
8am 8.03am 8.6am 8.9am 8.12am 8.12am
If a bottle starts to manufacture at 8am in the morning it finished by 8.12am.
Answer to the question no:3
Raw water
tank
Pump Step: 2 Quartz sand
filter
Step:3
Carbon Filter
(Activated)
Fine filter
Step: 4
Step:5 Ozone
generator
Gas
water
mixer
Answer to the queation no 4: